Hostname: page-component-848d4c4894-sjtt6 Total loading time: 0 Render date: 2024-06-14T11:30:14.207Z Has data issue: false hasContentIssue false
  • English
  • Français

The effects of surfactants on drop deformation and breakup

Published online by Cambridge University Press:  26 April 2006

H. A. Stone  and
L. G. Leal
H. A. Stone
Affiliation:
Division of Applied Sciences, Harvard University, Cambridge, MA 02138, USA
L. G. Leal
Affiliation:
Department of Chemical & Nuclear Engineering, University of California at Santa Barbara, Santa Barbara, CA 93106, USA
Get access Rights & Permissions [Opens in a new window]

Abstract

The effects of surface-active agents on drop deformation and breakup in extensional flows at low Reynolds numbers are described. In this free-boundary problem, determination of the interfacial velocity requires knowledge of the distribution of surfactant, which, in turn, requires knowledge of the interfacial velocity field. We account for this explicit coupling of the unknown drop shape and the evolving surfactant distribution. An analytical result valid for nearly spherical distortions is presented first. Finite drop deformation is studied numerically using the boundary-integral method in conjunction with the time-dependent convective–diffusion equation for surfactant transport. This procedure accurately follows interfacial tension variations, produced by non-uniform surfactant distribution, on the evolving interface. The numerical method allows for an arbitrary equation of state relating interfacial tension to the local concentration of surfactant, although calculations are presented only for the common linear equation of state. Also, only the case of insoluble surfactant is studied.

The analytical and numerical results indicate that at low capillary numbers the presence of surfactant causes larger deformation than would occur for a drop with a constant interfacial tension equal to the initial equilibrium value. The increased deformation occurs owing to surfactant being swept to the end of the drop where it acts to locally lower the interfacial tension, which therefore requires increased deformation to satisfy the normal stress balance. However, at larger capillary numbers and finite deformations, this convective effect competes with ‘dilution’ of the surfactant due to interfacial area increases. These two different effects of surface-active material are illustrated and discussed and their influence on the critical capillary number for breakup is presented.

Type
Research Article
Information
Journal of Fluid Mechanics , Volume 220 , November 1990 , pp. 161 - 186
Copyright
© 1990 Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Acrivos, A.: 1983 The breakup of small drops and bubbles in shear flows. Ann. NY Acad. Sci. 404, 1–11.Google Scholar
Adamson, A. W.: 1976 Physical Chemistry of Surfaces, 3rd edn. John Wiley & Sons.
Aris, R.: 1962 Vectors, Tensors and the Basic Equations of Fluid Mechanics. Prentice-Hall.
Ascoli, E. P. & Leal, L. G., 1990 Thermocapillary migration of a deformable drop toward a planar wall. J. Colloid Interface Sci. (accepted).Google Scholar
Barthes-Biesel, D. & Acrivos, A. 1973 Deformation and burst of a liquid droplet freely suspended in a linear shear field. J. Fluid Mech. 61, 1–21.Google Scholar
Bentley, B. J. & Leal, L. G., 1986 An experimental investigation of drop deformation and breakup in steady two-dimensional linear flows. J. Fluid Mech. 167, 241–283.Google Scholar
Cox, R. G.: 1969 The deformation of a drop in a general time-dependent fluid flow. J. Fluid Mech. 37, 601–623.Google Scholar
Flumerfelt, R. W.: 1980 Effects of dynamic interfacial properties on drop deformation and orientation in shear and extensional flow fields. J. Colloid Interface Sci. 76, 330–349.Google Scholar
Frankel, N. A. & Acrivos, A., 1970 The constitutive equation for a dilute emulsion. J. Fluid Mech. 44, 65–78.Google Scholar
Greenspan, H. P.: 1978 On fluid-mechanical simulations of cell division and movement. J. Theor. Biol. 70, 125–134.Google Scholar
Haber, S. & Hetsroni, G., 1971 Hydrodynamics of a drop submerged in an unbounded arbitrary velocity field in the presence of surfactants. Appl. Sci. Res. 25, 215–233.Google Scholar
Holbrook, J. A. & Levan, M. D., 1983a Retardation of droplet motion by surfactant. Part 1. Theoretical development and asymptotic solutions. Chem. Engng Commun. 20, 191–207.Google Scholar
Holbrook, J. A. & Levan, M. D., 1983b Retardation of droplet motion by surfactant. Part 2. Numerical solutions for exterior diffusion, surface diffusion and adsorption kinetics. Chem. Engng Commun. 20, 273–290.Google Scholar
Lee, S. H. & Leal, L. G., 1982 The motion of a sphere in the presence of a deformable interface. II. A numerical study of the translation of a sphere normal to an interface. J. Colloid Interface Sci. 87, 81–106.Google Scholar
Levan, M. D. & Newman, J., 1976 The effect of surfactant on the terminal and interfacial velocities of a bubble or drop. AIChE J. 22, 695–701.Google Scholar
Levich, V. G.: 1962 Physicochemical Hydrodynamics. Prentice-Hall.
Levich, V. G. & Krylov, V. S., 1958 Surface-tension-driven phenomena. Ann. Rev. Fluid Mech. 1, 293–316.Google Scholar
Li, X. Z., Barthes-Biesel, X. X. & Helmy, A. 1988 Large deformations and burst of a capsule freely suspended in an elongational flow. J. Fluid Mech. 187, 179–196.Google Scholar
Mcconnell, A. J.: 1957 Applications of Tensor Analysis. Dover.
Newman, J.: 1967 Retardation of falling drops. Chem. Engng Sci. 22, 83–85.Google Scholar
Phillips, W. J., Graves, R. W. & Flumerfelt, R. W., 1980 Experimental studies of drop dynamics in shear fields: Role of dynamic interfacial effects. J. Colloid Interface Sci. 76, 350–370.Google Scholar
Rallison, J. M.: 1980 A note on the time-dependent deformation of a viscous drop which is almost spherical. J. Fluid Mech. 98, 625–633.Google Scholar
Rallison, J. M.: 1981 A numerical study of the deformation and burst of a viscous drop in general shear flows. J. Fluid Mech. 109, 465–482.Google Scholar
Rallison, J. M.: 1984 The deformation of small viscous drops and bubbles in shear flows. Ann. Rev. Fluid Mech. 16, 45–66.Google Scholar
Rallison, J. M. & Acrivos, A., 1978 A numerical study of the deformation and burst of a viscous drop in general shear flows. J. Fluid Mech. 89, 191–200.Google Scholar
Rumscheidt, F. D. & Mason, S. G., 1961 Particle motions in sheared suspensions XII. Deformation and burst of fluid drops in shear and hyperbolic flow. J. Colloid Sci. 16, 238–261.Google Scholar
Sadhal, S. S. & Johnson, R. E., 1986 On the deformation of drops and bubbles with varying interfacial tension. Chem. Engng Commun. 46, 97–109.Google Scholar
Saville, D. A.: 1973 The effect of interfacial tension gradients on the motion of drops and bubbles. Chem. Engng J. 5, 251–259.Google Scholar
Sherwood, J. D.: 1988 Breakup of fluid droplets in electric and magnetic fields. J. Fluid Mech. 188, 133–146.Google Scholar
Smith, P. G. & Van De Ven, T. G. M.: 1985 Shear-induced deformation and rupture of suspended solid/liquid clusters. Colloids and Surfaces 15, 191–210.Google Scholar
Stone, H. A.: 1990 A simple derivation of the time-dependent convective–diffusion equation for surfactant transport along a deforming interface. Phys. Fluids A 2, 111–112.Google Scholar
Stone, H. A., Bentley, B. J. & Leal, L. G., 1986 An experimental study of transient effects in the breakup of viscous drops. J. Fluid Mech. 173, 131–158.Google Scholar
Stone, H. A. & Leal, L. G., 1989 Relaxation and breakup of an initially extended drop in an otherwise quiescent fluid. J. Fluid Mech. 198, 399–427.Google Scholar
Stoos, J. A. & Leal, L. G., 1989 Particle motion in axisymmetric stagnation flow toward an interface. AIChE J. 35, 196–212.Google Scholar
Taylor, G. I.: 1932 The viscosity of a fluid containing small drops of another fluid. Proc. R. Soc. Lond. A 138, 41–48.Google Scholar
Taylor, G. I.: 1934 The formation of emulsions in definable fields of flow. Proc. R. Soc. Lond. A 146, 501–523.Google Scholar
Torza, S., Cox, R. G. & Mason, S. G., 1972 Particle motions in sheared suspensions. XXVII. Transient and steady deformation and burst of liquid drops. J. Colloid Interface Sci. 38, 395–411.Google Scholar
Waxman, A. M.: 1984 Dynamics of a couple-stress fluid membrane. Stud. Appl. Maths 70, 63–86.Google Scholar
Zinemanas, D. & Nir, A., 1988 On the viscous deformation of biological cells under anisotropic surface tension. J. Fluid Mech. 193, 217–241.Google Scholar