Skip to main content
×
Home
    • Aa
    • Aa

Effect of film chemistry on refractive index of plasma-enhanced chemical vapor deposited silicon oxynitride films: A correlative study

  • S. Naskar (a1), S.D. Wolter (a2), C.A. Bower (a3), B.R. Stoner (a1) and J.T. Glass (a2)...
Abstract

Thick SiOxNy films were deposited by radiofrequency (rf) plasma chemical vapor deposition using silane (SiH4) and nitrous oxide (N2O) source gases. The influence of deposition conditions of gas flow ratio, rf plasma mixed-frequency ratio (100 kHz, 13.56 MHz), and rf power on the refractive index were examined. It was observed that the refractive index of the SiOxNy films increased with N and Si concentration as measured via x-ray photoelectron spectroscopy. Interestingly, a variation of refractive index with N2O:SiH4 flow ratio for the two drive frequencies was observed, suggesting that oxynitride bonding plays an important role in determining the optical properties. The two drive frequencies also led to differences in hydrogen concentration that were found to be correlated with refractive index. Hydrogen concentration has been linked to significant optical absorption losses above index values of ∼1.6, which we identified as a saturation level in our films.

Copyright
Corresponding author
a)Address all correspondence to this author. e-mail: woltersd@duke.edu
Linked references
Hide All

This list contains references from the content that can be linked to their source. For a full set of references and notes please see the PDF or HTML where available.

1 R. Germann , H.W.M. Salemink , R. Beyeler , G.L. Bona , F. Horst , I. Massarek B.J. Offrein : Silicon oxynitride layers for optical waveguide applications. J. Electrochem. Soc. 147(6), 22372000

2 K.E. Mattsson : Plasma enhanced growth, composition and refractive index of silicon oxynitride films. J. Appl. Phys. 77(12), 66161995

3 M.I. Alayo , I. Pereyra M.N.P. Carreno : Thick SiOxNy and SiO2 films obtained by PECVD technique at low temperatures. Thin Solid Films 332, 401998

4 M.I. Alayo , I. Pereyra , W.L. Scopel M.C.A. Fantini : On the nitrogen and oxygen incorporation in plasma-enhanced chemical vapor deposition (PECVD) SiOxNy films. Thin Solid Films 402, 1542002

7 K. Worhoff , A. Driessen , P.V. Lambeck , L.T.H. Hilderink , P.W.C. Linders Th.J.A. Popma : Plasma enhanced chemical vapor deposition silicon oxynitride optimized for application in integrated optics. Sens. Actuators 74, 91999

8 K. Worhoff , P.V. Lambeck A. Driessen : Design, tolerance analysis and fabrication of silicon oxynitride based planar optical waveguides for communication devices. J. Light-wave Technol. 17(8), 14011999

9 D.V. Tsu , G. Lucovsky , M.J. Mantini S.S. Chao : Deposition of silicon oxynitride thin films by remote plasma enhanced chemical vapor deposition. J. Vac. Sci. Technol., A 5, 19981987

10 G. Lucovsky , P.D. Richard , D.V. Tsu , S.Y. Lin R.J. Markunas : Deposition of silicon dioxide and silicon nitride by remote plasma enhanced chemical vapor deposition. J. Vac. Sci. Technol., A 4, 6811986

11 S.S. Chao , J.E. Tyler , D.V. Tsu , G. Lucovsky M.J. Mantini : Auger electron spectroscopy studies of silicon nitride, oxide, and oxynitride thin films: Minimization of surface damage by argon and electron beams. J. Vac. Sci. Technol., A 5, 12831987

12 M.L. Green , E.P. Gusev , R. Degraeve E.L. Garfunkel : Ultrathin (<4 nm) SiO2 and Si–O–N gate dielectric layers for silicon microelectronics: Understanding the processing, structure, and physical and electrical limits. J. Appl. Phys. 90, 20572001

13 E.P. Gusev , H.C. Lu , E. Garfunkel , T. Gustafsson , M.L. Green , D. Brasen W.N. Lennard : Nitrogen engineering of ultrathin oxynitrides by a thermal NO/O2/NO process. J. Appl. Phys. 84, 29801998

14 E.P. Gusev , H.C. Lu , T. Gustafsson , E. Garfunkel , M.L. Green D. Brasen : The composition of ultrathin silicon oxynitrides thermally grown in nitric oxide. J. Appl. Phys. 82, 8961997

15 H.C. Lu , E.P. Gusev , T. Gustafsson E. Garfunkel : Effect of near-interfacial nitrogen on the oxidation behavior of ultrathin silicon oxynitrides. J. Appl. Phys. 81, 69921997

16 B.H. Augustine , E.A. Irene , Y.J. He , K.J. Price , L.E. McNeil , K.N. Kristensen D.M. Maher : Visible light emission from thin films containing Si, O, N, and H. J. Appl. Phys. 78(6), 40201995

19 D.L. Smith : A.S. Alimonda, C-C. Chen, S.E. Ready, and B. Wacker: Mechanism of SiNxHy deposition from NH3–SiH4 plasma. J. Electrochem. Soc. 137, 6141990

20 D.L. Smith , A.S. Alimonda F.J. Von Preissig : Mechanism of SiNxHy deposition from N2–SiH4 plasma. J. Vac. Sci. Technol., B 8, 5511990

21 S. Naskar , C.A. Bower , S.D. Wolter , B.R. Stoner J.T. Glass : Verification of the O–Si–N complex in plasma-enhanced chemical vapor deposition silicon oxynitride films. Appl. Phys. Lett. 87, 261,9072005

Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Journal of Materials Research
  • ISSN: 0884-2914
  • EISSN: 2044-5326
  • URL: /core/journals/journal-of-materials-research
Please enter your name
Please enter a valid email address
Who would you like to send this to? *
×

Keywords: