Skip to main content
×
Home
    • Aa
    • Aa

TEM Investigation of Nanophase Aluminum Powder

  • Valéry Y. Gertsman (a1) and Queenie S.M. Kwok (a2)
Abstract

Nanophase aluminum powder was characterized in a field-emission-gun transmission electron microscope (TEM). Different techniques were used to investigate the structure of the particles, including conventional bright-field and dark-field imaging, scanning transmission electron microscopy (STEM), high-resolution lattice imaging, diffraction studies, energy dispersive X-ray spectroscopy (EDS) analysis and mapping, and electron energy loss spectroscopy (EELS) analysis and mapping. It has been established that the particle cores consist of aluminum single crystals that sometimes contain crystal lattice defects. The core is covered by a passivating layer of aluminum oxide a few nanometers thick. The alumina is mostly amorphous, but evidences of partial crystallinity of the oxide were also found. The thickness of this layer was measured using different techniques, and the results are in good agreement with each other. The particles are agglomerated in two distinct ways. Some particles were apparently bonded together during processing before oxidation. These mostly form dumbbells covered by a joint oxide layer. Also, oxidized particles are loosely assembled into relatively large clusters.

Copyright
Corresponding author
Corresponding author. E-mail: Val.Gertsman@NRCan.gc.ca
Linked references
Hide All

This list contains references from the content that can be linked to their source. For a full set of references and notes please see the PDF or HTML where available.

Aumann, C.E., Skofronick, G.L., & Martin, J.A. (1995). Oxidation behavior of aluminum nanopowders. J Vac Sci Technol B13, 11781183.

Bouchet, D. & Colliex, C. (2003). Experimental study of ELNES at grain boundaries in alumina: Intergranular radiation damage effects on Al-L23 and O-K edges. Ultramicroscopy96, 139152.

Bourdillon, A.J., El-Mashr, S.M., & Forty, A.J. (1984). Application of TEM extended electron energy loss fine structure to the study of aluminum oxide films. Phil Mag A49, 341352.

Brousseau, P. & Anderson, C.J. (2002). Nanometric aluminum in explosives. Propellants, Explosives, Pyrotechnics27, 300306.

Eckert, J., Holzer, J.C., Ahn, C.C., Fu, Z., & Johnson, W.L. (1993). Melting behavior of nanocrystalline aluminum powders. Nanostruct Mater2, 407413.

Fernandez, A., Sanchez-Lopez, J.C., Caballero, A., Martin, J.M., Vacher, B., & Ponsonnet, L. (1998). Characterisation of nanophase Al-oxide/Al powders by electron energy-loss spectroscopy. J Microsc191, 212220.

Jones, D.E.G., Turcotte, R., Fouchard, R.C., Kwok, Q.S.M., Turcotte, A-M., & Abdel-Qader, Z. (2003). Hazard characterization of aluminum nanopowder compositions. Propellants, Explosives, Pyrotechnics28, 229.

Kwok, Q.S.M., Fouchard, R.C., Turcotte, A.-M., Lightfoot, P.D., Bowes, R., & Jones, D.E.G. (2002). Characterization of aluminum nanopowder compositions. Propellants, Explosives, Pyrotechnics27, 229240.

Levin, I. & Brandon, D. (1998). Metastable alumina polymorphs: Crystal structure and transition sequences. J Am Ceram Soc81, 19952012.

Sako, S., Oshima, K., & Fujita, T. (1990). Surface oxide film of small particle. J Phys Soc Japan59, 662666.

Sanchez-Lopez, J.C., Caballero, A., & Fernandez, A. (1998). Characterisation of passivated aluminum nanopowders: An XPS and TEM/EELS study. J Euro Ceram Soc18, 11951200.

Suits, B.H., Apte, P., Wilke, D.E., & Siegel, R.W. (1995). NMR study of nanophase Al/Al-oxide powder and consolidated composites. Nanostruct Mater6, 609612.

Sun, X.K., Xu, J., Chen, W.X., & Wei, W.D. (1994). Preparation of Al nanoparticles in a controlled environment. Nanostruct Mater4, 337344.

Tanaka, N., Yamasaki, J., Mitani, S., & Takanashi, K. (2003). High-angle annular dark-field scanning transmission electron microscopy and energy-loss spectroscopy of nano-granular Co-Al-O alloys. Scripta Mater48, 909914.

Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Microscopy and Microanalysis
  • ISSN: 1431-9276
  • EISSN: 1435-8115
  • URL: /core/journals/microscopy-and-microanalysis
Please enter your name
Please enter a valid email address
Who would you like to send this to? *
×

Keywords: