Hostname: page-component-8448b6f56d-jr42d Total loading time: 0 Render date: 2024-04-25T01:09:25.721Z Has data issue: false hasContentIssue false
  • English
  • Français

The Growth of Optical Quality LiNbo3 Thin Films On Sapphire and LiTao3 Substrates Using Solid-Source Mocvd

Published online by Cambridge University Press:  21 February 2011

S. Y. Lee ,
R. K. Route  and
R. S. Feigelson
S. Y. Lee
Affiliation:
Dept. of Materials Science and Engineering, Stanford University, CA 94305-2205
R. K. Route
Affiliation:
Center for Materials Research, Stanford University, CA 94305-4045
R. S. Feigelson
Affiliation:
Dept. of Materials Science and Engineering, Stanford University, CA 94305-2205
Get access

Abstract

High quality lithium niobate (LiNbO3) epitaxial thin films have been grown on c-plane sapphire and LiTaO3 substrates by solid-source MOCVD using the tetramethyl-heptanedionate sources, Li(thd) and Nb(thd)4. Phase content was controllable, and stoichiometric films were reproducibly deposited over a broad temperature range from a Li(thd)-rich source. Using sapphire substrates, with which the occurrence of multiple in-plane orientations is typically a problem, LiNbO3 films with only one in-plane orientation could be prepared within a narrow range of growth conditions. XRD rocking curve FWHM values as low as 0.04°, and optical waveguiding losses near 2dB/cm (1200Å thick film, TMo mode, 632.8nm) were obtained. However, film thicknesses on sapphire were limited to 2000Å because of cracking caused by the large thermal expansion mismatch, and in such thin films, optical confinement is poor.

In contrast, LiTaO3 has almost same lattice constants and thermal expansion coefficients as LiNbO3, making it a potentially superior substrate material. Lithium niobate films up to 6000Å were successfully deposited on LiTaO3 substrates without cracking. Film quality was greatly improved, with FWHM values as low as 0.01°, and rms surface roughness less than 10 Å. Preliminary optical waveguiding losses less than 6 dB/cm for the TEo mode have been achieved.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 392: Symposium U – Thin Films for Integrated Optics Applications , 1995 , 177
Copyright
Copyright © Materials Research Society 1995

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1. Weis, R.S. and Gaylord, T.K., Appl. Phys. A37, 191 (1985).Google Scholar
2. Sohler, W., Thin Solid Films 175, 191 (1989).Google Scholar
3. Yamada, A., Tamada, H. and Saitoh, M., Appl. Phys. Lett. 61, 2848 (1992).Google Scholar
4. Tamada, H., Yamada, A. and Saitoh, M., J. Appl. Phys. 70, 2848 (1992).Google Scholar
5. Miyazawa, S., Appl. Phys. Lett. 23, 198 (1973).Google Scholar
6. Nashimoto, K. and Cima, M.J., Mater. Lett. 10 348 (991).Google Scholar
7. Schwyn, S., Lehmann, H.W. and Widmer, R., J.Appl. Phys. 72, 1154 (1992).Google Scholar
8. Rost, T.A., Lin, H. and Rabson, T.A., J. Appl. Phys. 72 (9), 4336 (1992).Google Scholar
9. Marsh, A.M., Harkness, S.D., Qian, F. and Singh, R.K., Appl. Phys. Lett. 62, 946 (1993).Google Scholar
10. Betts, R.A. and Pitt, C.W., Elect. Lett. 21, 960 (1985).Google Scholar
11. Wernberg, A.A., Gysling, H.J. and Braunstein, G., J. Crystal Growth 140, 57 (1994).Google Scholar
12. Hiskes, R., DiCarolis, S.A., Fouquet, J.E., Lu, Z., Route, R.K., Feigelson, R.S., Leplingard, F. and Foster, C.M., Mat. Res. Soc. Symp. Pro. 335, 299 (1994).Google Scholar
13. Fork, D.K., Leplingard, F. and Kingston, J.J., presented at 1994 MRS Fall Meeting, Boston, MA, (to be published in the proceedings).Google Scholar
14. Lu, Z., Feigelson, R.S., Route, R.K., DiCarolis, S.A., Hiskes, R. and Jacowitz, R.D., J. Cryst. Growth 128, 788 (1993).Google Scholar
15. Wernberg, A.A., Gysling, H.J., Filo, A.J. and Blanton, T.N., Appl. Phys. Lett. 62 (9), 946 (1993).Google Scholar
16. Lu, Z., Hiskes, R., DiCarolis, S.A., Route, R.K., Feigelson, R.S., Leplingard, F. and Fouquet, J.E., J. Mater. Res. 9, 2258 (1994).Google Scholar
17. Ohring, M., The Materials Science of Thin Films, (Academic Press Inc., San Diego, 1992), pp. 197–213.Google Scholar
18. Lu, Z., Ph. D. Dissertation, Stanford University (1995), pp 95–99.Google Scholar
19. Flynn, C.P., J. Phys. F: Net. Phys. 18, L195 (1988).Google Scholar
20. Stringfellow, G.B., Organo-Metallic Vapor-Phase Epitaxy: Theory and Practice, (Academic Press, Inc., San Diego, 1989).Google Scholar
21. Kwak, B.S., Zhang, K., Boyd, E.P. and Erbil, A., J. Appl. Phys. 69, 767 (1991).Google Scholar