Hostname: page-component-8448b6f56d-m8qmq Total loading time: 0 Render date: 2024-04-23T07:57:28.458Z Has data issue: false hasContentIssue false
  • English
  • Français

Simultaneous Real Time Spectroscopic Ellipsometry and Reflectance for Monitoring Semiconductor and Thin Film Preparation

Published online by Cambridge University Press:  22 February 2011

Ilsin An ,
Hien V. Nguyen ,
A. R. Heyd  and
R. W. Collins
Ilsin An
Affiliation:
Materials Research Laboratory and Department of Physics, The Pennsylvania State University, University Park, PA 16802
Hien V. Nguyen
Affiliation:
Materials Research Laboratory and Department of Physics, The Pennsylvania State University, University Park, PA 16802
A. R. Heyd
Affiliation:
Materials Research Laboratory and Department of Physics, The Pennsylvania State University, University Park, PA 16802
R. W. Collins
Affiliation:
Materials Research Laboratory and Department of Physics, The Pennsylvania State University, University Park, PA 16802
Get access

Abstract

This paper describes an expansion of the capabilities of real time spectroscopic ellipsometry (SE) that results from simultaneous measurement of a reflectance spectrum RA along with the two spectra in the ellipsometric angles (Ψ,δ). RA provides information complementary to (Ψ,δ), but until now has not been exploited in real time spectroscopic applications. Earlier, we have developed a novel rotating-polarizer multichannel ellipsometer for real time studies of thin film growth that utilizes a photodiode array (PDA) detector for highspeed acquisition of (Ψ,δ) spectra. Employing this instrument with a 12.5 Hz polarizer rotation rate, three-parameter (3-p) data sets {Ψ(hv,t), δ(hv,t), RA(hv,t); 1.4≤hv≤4.5 eV} can now be obtained with a time resolution as short as 40 ms during film growth. A resilient new analysis approach based on mathematical inversion and least-squares fitting is described to interpret the 3-p data set. The 3-p approach has been successful in characterizing plasmaenhanced chemical vapor deposition (PECVD) of amorphous semiconductors, and provides the film dielectric functions and thicknesses independently at each time during film growth. RA(hV) exhibits deviations from the spectrum predicted in successful modeling of (Ψ,δ) spectra alone. These deviations result from diffuse light scattering by particulates in the plasma. We show how additional information can be extracted from the spectral dependence of the scattering loss.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 324: Symposium K – Diagnostic Techniques for Semiconductor Materials Processing , 1993 , 33
Copyright
Copyright © Materials Research Society 1994

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

[1] Collins, R.W., Rev. Sci. Instrum. 61, 2029 (1990).CrossRefGoogle Scholar
[2] Aspnes, D.E., in Optical Properties of Solids: New Developments, edited by Seraphin, B.O. (North-Holland, Amsterdam, 1976) Chapt. 15, p. 799.Google Scholar
[3] An, I., Li, Y.M., Nguyen, H.V., and Collins, R.W., Rev. Sci. Instrum. 63, 3842 (1992).CrossRefGoogle Scholar
[4] An, I., Cong, Y., Nguyen, N.V., and Pudliner, B.S., Thin Solid Films 206, 300 (1991).Google Scholar
[5] Aspnes, D.E., Theeten, J.B., and Hottier, F., Phys. Rev. B 20, 3292 (1979).Google Scholar
[6] Toyoshima, Y., Arai, K., Matsuda, A., and Tanaka, K., Appl. Phys. Lett. 57, 1028 (1990).Google Scholar
[7] Burge, D.K. and Bennett, H.E., J. Opt. Soc. Am. 54, 1428 (1964).Google Scholar
[8] Paik, W.-K. and Bockris, J. O'M., Surf. Sci. 28, 60 (1971).Google Scholar
[9] Cahan, B.D., Surf. Sci. 56, 354 (1976).Google Scholar
[10] Hamnett, A., Higgins, S., Fisk, P., and Albery, W., Electroanal. Chem. 270, 479 (1989).Google Scholar
[11] Veprek, S. et al. , Mater. Res. Soc. Symp. Proc. 297, 13 (1993).Google Scholar