Hostname: page-component-8448b6f56d-gtxcr Total loading time: 0 Render date: 2024-04-25T00:31:21.377Z Has data issue: false hasContentIssue false
  • English
  • Français

A Study of Grain Growth in Ion Irradiated Co-Cr Alloy Films*

Published online by Cambridge University Press:  25 February 2011

J. Li ,
B. X. Liu  and
H. D. Li
J. Li
Affiliation:
Department of Engineering Physics, Tsinghua University Beijing, China
B. X. Liu
Affiliation:
Department of Engineering Physics, Tsinghua University Beijing, China
H. D. Li
Affiliation:
Department of Engineering Physics, Tsinghua University Beijing, China
Get access

Abstract

Experiments concerning the behavior of grain size in Co80Cr20 alloy thin films upon ion irradiation were conducted. The alloy films of 80 nm thick were prepared by magnetron sputtering on cleaved NaCl crystal substrates, and then irradiated by 300 keV argon or xenon ions to a wide range of doses. The irradiated samples, before and after annealing, were examined by transmission electron microscope (TEM). It was found that the initial grain size with the dimension of 20 nm remained unchanged when the dose was less than 1×1016Ar/cm2, but rapidly reduced to the scale of 5 nm at a dose of 5×1016Ar/cm2. It is thought that this is due to a polymorphic transformation of an HCP to a BCC structure in the alloy films. After 30 min. anneals at 200° C, it was observed that the grain growth rate was a function of ion dose, and that there exists a critical fluence yielding a maximum grain growth rate. The possible mechanisms for the observations in this study are discussed.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 93: Symposium C – Materials Modification and Growth Using Ion Beams , 1987 , 105
Copyright
Copyright © Materials Research Society 1987

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

Footnotes

*

Project supported in part by the Science Fund of the Chinese Academy of Sciences.

References

REFERENCES

1. Bhattacharyya, A. and Ritz, K. N., J. Electrochem. Soc. 191, 2143 (1984).Google Scholar
2. Iverson, R. B. and Reif, R., J. Appl. Phys. 57, 5169 (1985).Google Scholar
3. Gaboriaud, R. J., Jaouen, C., Grob, J. J. and Grob, A., Appl. Phys. A 41, 127 (1984).Google Scholar
4. Tsaur, B. Y. and Mayer, J. W., Appl. Phys. Lett. 37, 389 (1980).Google Scholar
5. Liu, J. C. and Mayer, J. W., Nucl. Instr. Meth. B19/20, 538 (1987).Google Scholar
6. Chen, T., Yamashita, T. and Sinclair, R., IEEE Trans. Mag. Vol. Mag.–7, 3187 (1981).Google Scholar
7. Liu, B. X., Ma, E., Li, J. and Huang, L. J., Nucl. Instr. Meth. B19/20, 682 (1987).Google Scholar
8. Huang, L. J. and Liu, B. X., Nucl. Instr. Meth. B18, 256 (1987).Google Scholar
9. Cotterill, P. and Mould, P. R., in Recrystallization and Grain Growth in Metals, London, Surry Univ. Press, (1976).Google Scholar
10. Langier, M., Thin Solid Films 75, 213 (1980).Google Scholar