Hostname: page-component-76fb5796d-25wd4 Total loading time: 0 Render date: 2024-04-25T17:32:18.025Z Has data issue: false hasContentIssue false
  • English
  • Français

Structure of the Ti-Single Crystal Si Interface

Published online by Cambridge University Press:  25 February 2011

S. Ogawa ,
T. Kouzaki ,
T. Yoshida  and
R. Sinclair
S. Ogawa
Affiliation:
Matsushita Electric Ind. Co., Ltd., Semiconductor Research Center, Moriguchi, Osaka, Japan
T. Kouzaki
Affiliation:
Matsushita Technoresearch, Moriguchi, Osaka, Japan
T. Yoshida
Affiliation:
Matsushita Electric Ind. Co., Ltd., Semiconductor Research Center, Moriguchi, Osaka, Japan
R. Sinclair
Affiliation:
Dept. of Materials Science & Engineering, Stanford Univ., Stanford, CA
Get access

Abstract

The Ti-single crystal Si interfaces, before and after annealing in argon, were examined by cross section high resolution transmission electron microscopy (HRTEM) combined for the first time with 2nmΦ probe for energy dispersive spectrometry (EDS). HRTEM shows that there is amorphous alloy formation at the Ti-Si interface. The thickness of the reacted layer is ∼1.7nm for single crystal Si, independent of doping level and impurity species such as As and B, and is ∼2.5nm for back sputter-amorphized Si. After annealing at 430°C for 30min, the thickness of the amorphous alloy increases up to ∼11.5nm. High spatial resolution EDS microanalysis has been obtained. The results show that reliable compositions can be deduced at this level since some of the layers are only about 2nm thick. The amorphous alloy formed at the deposition step was found to be Ti55Si45. After annealing, the composition across the amorphous layer varied from about 70%Si near the substrate to about 30%S1 close to the Ti interface. The substrate interface is atomically flat. Interpretation of the behavior in terms of the metastable Ti-Si phase diagram calculated by Holloway and Bormann will be discussed.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 181: Symposium B – Advanced Metallizations in Microelectronics , 1990 , 139
Copyright
Copyright © Materials Research Society 1990

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

[1] Hui, J., Wong, S., and Moll, J., IEEE Electron Device Letters, vol.EDL–6, 479 (1985)CrossRefGoogle Scholar
[2] Holloway, K. and Sinclair, R., J. Appl. Phys. 61, 1339 (1987)CrossRefGoogle Scholar
[3] Yanaka, T., Moriyama, K., and Buchanan, R., Mats. Res. Soc. Symp. Proc. vol.139 271 (1989)CrossRefGoogle Scholar
[4] Cliff, G. and Lorimer, G., Proc. 5th European Congress on Electron Microscopy, 140 (1972)Google Scholar
[5] Yanaka, T., Private communicationGoogle Scholar
[6] Zoltzer, K. and Bormann, R., J.Less Common Met. 140, 335.(1988)CrossRefGoogle Scholar
[7] Holloway, K., “Interfacial Reactions in Metal-Silicon Multilayers”, Ph.D.Thesis, Stanford University (1989)CrossRefGoogle Scholar
[8] Holloway, K., Moine, P., Delage, J., Sinclair, R., and Capuano, L., Mats. Res. Soc. Symp. Proc. in press (1990)Google Scholar
[9] Raaijmakers, I.J.M.M., Reader, A.H., and Oosting, P.H., J. Appl. Phys. 63, 2790 (1988)CrossRefGoogle Scholar