Hostname: page-component-f7d5f74f5-g2fc4 Total loading time: 0 Render date: 2023-10-04T12:12:50.574Z Has data issue: false Feature Flags: { "corePageComponentGetUserInfoFromSharedSession": true, "coreDisableEcommerce": false, "coreDisableSocialShare": false, "coreDisableEcommerceForArticlePurchase": false, "coreDisableEcommerceForBookPurchase": false, "coreDisableEcommerceForElementPurchase": false, "coreUseNewShare": true, "useRatesEcommerce": true } hasContentIssue false

Studies of Corrosion of Al Thin Films using Liquid Cell Transmission Electron Microscopy

Published online by Cambridge University Press:  29 April 2013

See Wee Chee
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Frances M. Ross
IBM T. J. Watson Research Center, Yorktown Heights, NY 10598, U.S.A.
David Duquette
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Robert Hull
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Get access


A fundamental understanding of the processes that occur during early stages of corrosion is traditionally limited by the dearth of techniques that probe the liquid-solid interface with both high spatial resolution and microstructural detail such as grain size and orientation. Here, we demonstrate that with a microfluidic liquid flow cell holder, we can track the progress of corrosion in situ in Al thin films with transmission electron microscopy (TEM). To mitigate the loss of resolution caused by imaging through liquid, we developed a method in which the liquid is temporarily de-wetted from the entire windowed area by switching the liquid stream from pure water to a mixture of ethanol and water. In the de-wetted region, we then collected images of the film microstructure with high spatial resolution over regular intervals while maintaining a low electron flux over the imaged area to minimize beam-induced effects. For as-deposited films, we find that the corrosion progresses in a fractal manner, consistent with reported behavior for films studied in water with low iron and chloride concentrations. For films that were subjected to rapid thermal annealing, we observe a higher density of pitting events, which we attribute to defects created by thermal stress in the oxide film. Furthermore, we observe that the pits can form at multiple locations in a single grain and are not confined to grain boundaries.

Copyright © Materials Research Society 2013

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)



Frankel, G.S., J. Electrochem. Soc. 145, 2186 (1998).10.1149/1.1838615CrossRef
de Jonge, N. and Ross, F.M., Nat. Nanotechnol. 6, 695 (2011).10.1038/nnano.2011.161CrossRef
Zheng, H., Smith, R.K., Jun, Y.-W., Kisielowski, C., Dahmen, U. and Alivisatos, A.P., Science 324, 1309 (2009).10.1126/science.1172104CrossRef
Zheng, H., Claridge, S.A., Minor, A.M., Alivisatos, A.P., and Dahmen, U., Nano Lett. 9, 2460 (2009).10.1021/nl9012369CrossRef
Williamson, M.J., Tromp, R.M., Vereecken, P.M., Hull, R. and Ross, F.M., Nat. Mater. 2, 532 (2003).10.1038/nmat944CrossRef
Hummingbird Scientific (
Klein, K.L., Anderson, I.M., and de Jonge, N., J. Microsc. 242, 117 (2011).10.1111/j.1365-2818.2010.03484.xCrossRef
Noh, K.W., Liu, Y., Sun, L. and Dillon, S.J., Ultramicroscopy 116, 34 (2012)10.1016/j.ultramic.2012.03.012CrossRef
White, E.R., Mecklenburg, M., Shevitski, B., Singer, S.B. and Regan, B.C., Langmuir 28, 3695 (2012)10.1021/la2048486CrossRef
Woehl, T.J., Jungjohann, K.L., Evans, J.E., Arslan, I., Ristenpart, W.D. and Browning, N.D., Ultramicroscopy, in press,, (2012).CrossRef
Balazs, L. and Gouyet, J., Physica A 217, 319 (1995)CrossRef
Proost, J., Baklanov, M. and Verbeeck, R., J. Solid State Electrochem. 2, 150 (1998)10.1007/s100080050080CrossRef
Smith, U., Kristensen, N., Ericson, F. and Schweitz, J.-Å., J. Vac. Sci. Technol. A 9, 2527 (1991)CrossRef
Hernandez, S., Griffin, A.J. Jr., Brotzen, F.R. and Dunn, C.F., J. Electrochem. Soc. 142, 1215 (1995)10.1149/1.2044154CrossRef
Szklarska-Smialowska, Z., Corros. Sci. 41, 17431767 (1999)10.1016/S0010-938X(99)00012-8CrossRef