Skip to main content
×
Home
    • Aa
    • Aa

The minimal-span channel for rough-wall turbulent flows

  • M. MacDonald (a1), D. Chung (a1), N. Hutchins (a1), L. Chan (a2), A. Ooi (a1) and R. García-Mayoral (a3)...
Abstract

Roughness predominantly alters the near-wall region of turbulent flow while the outer layer remains similar with respect to the wall shear stress. This makes it a prime candidate for the minimal-span channel, which only captures the near-wall flow by restricting the spanwise channel width to be of the order of a few hundred viscous units. Recently, Chung et al. (J. Fluid Mech., vol. 773, 2015, pp. 418–431) showed that a minimal-span channel can accurately characterise the hydraulic behaviour of roughness. Following this, we aim to investigate the fundamental dynamics of the minimal-span channel framework with an eye towards further improving performance. The streamwise domain length of the channel is investigated with the minimum length found to be three times the spanwise width or 1000 viscous units, whichever is longer. The outer layer of the minimal channel is inherently unphysical and as such alterations to it can be performed so long as the near-wall flow, which is the same as in a full-span channel, remains unchanged. Firstly, a half-height (open) channel with slip wall is shown to reproduce the near-wall behaviour seen in a standard channel, but with half the number of grid points. Next, a forcing model is introduced into the outer layer of a half-height channel. This reduces the high streamwise velocity associated with the minimal channel and allows for a larger computational time step. Finally, an investigation is conducted to see if varying the roughness Reynolds number with time is a feasible method for obtaining the full hydraulic behaviour of a rough surface. Currently, multiple steady simulations at fixed roughness Reynolds numbers are needed to obtain this behaviour. The results indicate that the non-dimensional pressure gradient parameter must be kept below 0.03–0.07 to ensure that pressure gradient effects do not lead to an inaccurate roughness function. An empirical costing argument is developed to determine the cost in terms of CPU hours of minimal-span channel simulations a priori. This argument involves counting the number of eddy lifespans in the channel, which is then related to the statistical uncertainty of the streamwise velocity. For a given statistical uncertainty in the roughness function, this can then be used to determine the simulation run time. Following this, a finite-volume code with a body-fitted grid is used to determine the roughness function for square-based pyramids using the above insights. Comparisons to experimental studies for the same roughness geometry are made and good agreement is observed.

Copyright
Corresponding author
Email address for correspondence: michael.macdonald@unimelb.edu.au
Linked references
Hide All

This list contains references from the content that can be linked to their source. For a full set of references and notes please see the PDF or HTML where available.

J. C. del Álamo , J. Jimenez , P. Zandonade  & R. D. Moser 2006 Self-similar vortex clusters in the turbulent logarithmic region. J. Fluid Mech. 561, 329358.

L. H. Benedict  & R. D. Gould 1996 Towards better uncertainty estimates for turbulence statistics. Exp. Fluids 22 (2), 129136.

M. Bernardini , S. Pirozzoli , M. Quadrio  & P. Orlandi 2013 Turbulent channel flow simulations in convecting reference frames. J. Comput. Phys. 232 (1), 16.

A. Busse  & N. D. Sandham 2012 Parametric forcing approach to rough-wall turbulent channel flow. J. Fluid Mech. 712, 169202.

L. Chan , M. MacDonald , D. Chung , N. Hutchins  & A. Ooi 2015 A systematic investigation of roughness height and roughness wavelength in turbulent pipe flow in the transitionally rough regime. J. Fluid Mech. 771, 743777.

C. Chin , A. S. H. Ooi , I. Marusic  & H. M. Blackburn 2010 The influence of pipe length on turbulence statistics computed from direct numerical simulation data. Phys. Fluids 22 (11), 115107.

H. Choi  & P. Moin 1994 Effects of the computational time step on numerical solutions of turbulent flow. J. Comput. Phys. 113 (1), 14.

D. Chung , L. Chan , M. MacDonald , N. Hutchins  & A. Ooi 2015 A fast direct numerical simulation method for characterising hydraulic roughness. J. Fluid Mech. 773, 418431.

D. Chung , J. P. Monty  & A. Ooi 2014 An idealised assessment of Townsend’s outer-layer similarity hypothesis for wall turbulence. J. Fluid Mech. 742, R3.

R. B. Dean 1978 Reynolds number dependence of skin friction and other bulk flow variables in two-dimensional rectangular duct flow. J. Fluids Engng 100 (2), 215223.

G. M. Di Cicca  & M. Onorato 2016 Roughness sub-layer investigation of a turbulent boundary layer. J. Turbul. 17 (1), 5174.

K. A. Flack , M. P. Schultz  & T. A. Shapiro 2005 Experimental support for Townsend’s Reynolds number similarity hypothesis on rough walls. Phys. Fluids 17 (3), 035102.

O. Flores  & J. Jiménez 2006 Effect of wall-boundary disturbances on turbulent channel flows. J. Fluid Mech. 566, 357376.

O. Flores  & J. Jiménez 2010 Hierarchy of minimal flow units in the logarithmic layer. Phys. Fluids 22 (7), 071704.

J. M. Hamilton , J. Kim  & F. Waleffe 1995 Regeneration mechanisms of near-wall turbulence structures. J. Fluid Mech. 287, 317348.

R. A. Handler , J. R. Saylor , R. I. Leighton  & A. L. Rovelstad 1999 Transport of a passive scalar at a shear-free boundary in fully developed turbulent open channel flow. Phys. Fluids 11 (9), 26072625.

J. Hong , J. Katz  & M. P. Schultz 2011 Near-wall turbulence statistics and flow structures over three-dimensional roughness in a turbulent channel flow. J. Fluid Mech. 667, 137.

S. Hoyas  & J. Jiménez 2008 Reynolds number effects on the Reynolds-stress budgets in turbulent channels. Phys. Fluids 20 (10), 101511.

Y. Hwang 2013 Near-wall turbulent fluctuations in the absence of wide outer motions. J. Fluid Mech. 723, 264288.

Y. Hwang 2015 Statistical structure of self-sustaining attached eddies in turbulent channel flow. J. Fluid Mech. 767, 254289.

Y. Hwang  & Y. Bengana 2016 Self-sustaining process of minimal attached eddies in turbulent channel flow. J. Fluid Mech. 795, 708738.

J. Jeong , F. Hussain , W. Schoppa  & J. Kim 1997 Coherent structures near the wall in a turbulent channel flow. J. Fluid Mech. 332, 185214.

J. Jiménez 2004 Turbulent flows over rough walls. Annu. Rev. Fluid Mech. 36, 173196.

J. Jiménez 2015 Direct detection of linearized bursts in turbulence. Phys. Fluids 27 (1), 065102.

J. Jiménez , G. Kawahara , M. P. Simens , M. Nagata  & M. Shiba 2005 Characterization of near-wall turbulence in terms of equilibrium and bursting solutions. Phys. Fluids 17 (1), 015105.

J. Jiménez  & P. Moin 1991 The minimal flow unit in near-wall turbulence. J. Fluid Mech. 225, 213240.

J. Jiménez  & A. Pinelli 1999 The autonomous cycle of near-wall turbulence. J. Fluid Mech. 389 (1), 335359.

M. B. Jones , I. Marusic  & A. E. Perry 2001 Evolution and structure of sink-flow turbulent boundary layers. J. Fluid Mech. 428, 127.

J. Kim 1989 On the structure of pressure fluctuations in simulated turbulent channel flow. J. Fluid Mech. 205, 421451.

K. C. Kim  & R. J. Adrian 1999 Very large-scale motion in the outer layer. Phys. Fluids 11 (2), 417422.

J. Kim  & P. Moin 1985 Application of a fractional-step method to incompressible Navier–Stokes equations. J. Comput. Phys. 59 (2), 308323.

S. J. Kline , W. C. Reynolds , F. A. Schraub  & P. W. Runstadler 1967 The structure of turbulent boundary layers. J. Fluid Mech. 30 (04), 741773.

M. Kozul , D. Chung  & J. P. Monty 2016 Direct numerical simulation of the incompressible temporally developing turbulent boundary layer. J. Fluid Mech. 796, 437472.

P. Lenaers , P. Schlatter , G. Brethouwer  & A. V. Johansson 2014 A new high-order method for the simulation of incompressible wall-bounded turbulent flows. J. Comput. Phys. 272, 108126.

S. Leonardi  & I. P. Castro 2010 Channel flow over large cube roughness: a direct numerical simulation study. J. Fluid Mech. 651, 519539.

A. Lozano-Durán  & J. Jiménez 2014 Effect of the computational domain on direct simulations of turbulent channels up to Re 𝜏 = 4200. Phys. Fluids 26 (1), 011702.

M. MacDonald , L. Chan , D. Chung , N. Hutchins  & A. Ooi 2016 Turbulent flow over transitionally rough surfaces with varying roughness density. J. Fluid Mech. 804, 130161.

K. Mahesh , G. Constantinescu  & P. Moin 2004 A numerical method for large-eddy simulation in complex geometries. J. Comput. Phys. 197, 215240.

I. Marusic , J. P. Monty , M. Hultmark  & A. J. Smits 2013 On the logarithmic region in wall turbulence. J. Fluid Mech. 716, R3.

Y. Mizuno  & J. Jiménez 2013 Wall turbulence without walls. J. Fluid Mech. 723, 429455.

W. Munters , C. Meneveau  & J. Meyers 2016 Shifted periodic boundary conditions for simulations of wall-bounded turbulent flows. Phys. Fluids 28 (2), 025112.

H. M. Nagib  & K. A. Chauhan 2008 Variations of von Kármán coefficient in canonical flows. Phys. Fluids 20, 101518.

T. A. Oliver , N. Malaya , R. Ulerich  & R. D. Moser 2014 Estimating uncertainties in statistics computed from direct numerical simulation. Phys. Fluids 26 (3), 035101.

V. C. Patel 1965 Calibration of the preston tube and limitations on its use in pressure gradients. J. Fluid Mech. 23 (01), 185208.

A. E. Perry  & P. N. Joubert 1963 Rough-wall boundary layers in adverse pressure gradients. J. Fluid Mech. 17 (02), 193211.

S. B. Pope 2000 Turbulent Flows. Cambridge University Press.

M. R. Raupach 1981 Conditional statistics of Reynolds stress in rough-wall and smooth-wall turbulent boundary layers. J. Fluid Mech. 108, 363382.

M. R. Raupach , R. A. Antonia  & S. Rajagopalan 1991 Rough-wall turbulent boundary layers. Appl. Mech. Rev. 44 (1), 125.

M. P. Schultz  & K. A. Flack 2009 Turbulent boundary layers on a systematically varied rough wall. Phys. Fluids 21, 015104.

M. Seddighi , S. He , A. E. Vardy  & P. Orlandi 2014 Direct numerical simulation of an accelerating channel flow. Flow Turbul. Combust. 92 (1–2), 473502.

A. Sekimoto , S. Dong  & J. Jiménez 2016 Direct numerical simulation of statistically stationary and homogeneous shear turbulence and its relation to other shear flows. Phys. Fluids 28, 035101.

P. R. Spalart  & J. D. McLean 2011 Drag reduction: enticing turbulence, and then an industry. Phil. Trans. R. Soc. Lond. A 369 (1940), 15561569.

P. R. Spalart , R. D. Moser  & M. M. Rogers 1991 Spectral methods for the Navier–Stokes equations with one infinite and two periodic directions. J. Comput. Phys. 96 (2), 297324.

S. Toh  & T. Itano 2005 Interaction between a large-scale structure and near-wall structures in channel flow. J. Fluid Mech. 524, 249262.

K. E. Trenberth 1984 Some effects of finite sample size and persistence on meteorological statistics. Part I: autocorrelations. Mon. Weath. Rev. 112 (12), 23592368.

Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Journal of Fluid Mechanics
  • ISSN: 0022-1120
  • EISSN: 1469-7645
  • URL: /core/journals/journal-of-fluid-mechanics
Please enter your name
Please enter a valid email address
Who would you like to send this to? *
×
MathJax

Keywords:

Metrics

Altmetric attention score

Full text views

Total number of HTML views: 11
Total number of PDF views: 302 *
Loading metrics...

Abstract views

Total abstract views: 570 *
Loading metrics...

* Views captured on Cambridge Core between 28th February 2017 - 26th September 2017. This data will be updated every 24 hours.