Skip to main content
×
Home

Practical Issues for Atom Probe Tomography Analysis of III-Nitride Semiconductor Materials

  • Fengzai Tang (a1), Michael P. Moody (a2), Tomas L. Martin (a2), Paul A.J. Bagot (a2), Menno J. Kappers (a1) and Rachel A. Oliver (a1)...
Abstract
Abstract

Various practical issues affecting atom probe tomography (APT) analysis of III-nitride semiconductors have been studied as part of an investigation using a c-plane InAlN/GaN heterostructure. Specimen preparation was undertaken using a focused ion beam microscope with a mono-isotopic Ga source. This enabled the unambiguous observation of implantation damage induced by sample preparation. In the reconstructed InAlN layer Ga implantation was demonstrated for the standard “clean-up” voltage (5 kV), but this was significantly reduced by using a lower voltage (e.g., 1 kV). The characteristics of APT data from the desorption maps to the mass spectra and measured chemical compositions were examined within the GaN buffer layer underlying the InAlN layer in both pulsed laser and pulsed voltage modes. The measured Ga content increased monotonically with increasing laser pulse energy and voltage pulse fraction within the examined ranges. The best results were obtained at very low laser energy, with the Ga content close to the expected stoichiometric value for GaN and the associated desorption map showing a clear crystallographic pole structure.

Copyright
Corresponding author
* Corresponding author. rao28@cam.ac.uk
References
Hide All
Agrawal R., Bernal R.A., Isheim D. & Espinosa H.D. (2011). Characterizing atomic composition and dopant distribution in wide band gap semiconductor nanowires using laser-assisted atom probe tomography. J Phys Chem C 115(36), 1768817694.
Ambacher O. (1998). Growth and applications of Group III nitrides. J Phys D: Appl Phys 31(20), 26532710.
Baloch K.H., Johnston-Peck A.C., Kisslinger K., Stach E.A. & Gradečak S. (2013). Revisiting the “In-clustering” question in InGaN through the use of aberration-corrected electron microscopy below the knock-on threshold. Appl Phys Lett 102(19), 191910.
Bennett S. (2011). Nitride Semiconductors Studied by Atom Probe Tomography and Correlative Techniques. Cambridge, UK: University of Cambridge.
Bennett S., Ulfig R., Clifton P., Kappers M., Barnard J., Humphreys C. & Oliver R. (2011). Atom probe tomography and transmission electron microscopy of a Mg-doped AlGaN/GaN superlattice. Ultramicroscopy 111(3), 207211.
Choi S., Jin Kim H., Lochner Z., Kim J., Dupuis R.D., Fischer A.M., Juday R., Huang Y., Li T. & Huang J.Y. (2014). Origins of unintentional incorporation of gallium in AlInN layers during epitaxial growth, part I: Growth of AlInN on AlN and effects of prior coating. J Cryst Growth 388, 137142.
Choi S., Wu F., Shivaraman R., Young E.C. & Speck J.S. (2012). Observation of columnar microstructure in lattice-matched InAlN/GaN grown by plasma assisted molecular beam epitaxy. Appl Phys Lett 100(23), 232102.
Cullen D.A. & Smith D.J. (2008). Assessment of surface damage and sidewall implantation in AlGaN-based high electron mobility transistor devices caused during focused-ion-beam milling. J Appl Phys 104(9), 094304.
Datta R., Kappers M., Vickers M., Barnard J. & Humphreys C. (2004). Growth and characterisation of GaN with reduced dislocation density. Superlattices Microstruct 36(4), 393401.
Dawahre N., Shen G., Renfrow S.N., Kim S.M. & Kung P. (2013). Atom probe tomography of AlInN/GaN HEMT structures. J Vac Sci Technol, B 31(4), 041802.
Devaraj A., Colby R., Hess W.P., Perea D.E. & Thevuthasan S. (2013). Role of photoexcitation and field ionization in the measurement of accurate oxide stoichiometry by laser-assisted atom probe tomography. J Phys Chem Lett 4(6), 993998.
Diercks D.R., Gorman B.P., Kirchhofer R., Sanford N., Bertness K. & Brubaker M. (2013). Atom probe tomography evaporation behavior of C-axis GaN nanowires: Crystallographic, stoichiometric, and detection efficiency aspects. J Appl Phys 114(18), 184903.
Galtrey M., Oliver R., Kappers M., McAleese C., Zhu D., Humphreys C., Clifton P., Larson D. & Cerezo A. (2008). Compositional inhomogeneity of a high-efficiency InxGa1-xN based multiple quantum well ultraviolet emitter studied by three dimensional atom probe. Appl Phys Lett 92(4), 041904.
Galtrey M.J., Oliver R.A., Kappers M.J., Humphreys C.J., Stokes D.J., Clifton P.H. & Cerezo A. (2007). Three-dimensional atom probe studies of an InxGa1−xN∕GaN multiple quantum well structure: Assessment of possible indium clustering. Appl Phys Lett 90(6), 061903.
Gault B., Moody M.P., Cairney J.M. & Ringer S.P. (2012). Atom Probe Microscopy. New York: Springer.
Gault B., Müller M., La Fontaine A., Moody M., Shariq A., Cerezo A., Ringer S. & Smith G. (2010). Influence of surface migration on the spatial resolution of pulsed laser atom probe tomography. J Appl Phys 108(4), 044904.
Götz W., Kern R., Chen C., Liu H., Steigerwald D. & Fletcher R. (1999). Hall-effect characterization of III–V nitride semiconductors for high efficiency light emitting diodes. Mater Sci Eng: B 59(1), 211217.
Gu G.H., Jang D.H., Nam K.B. & Park C.G. (2013). Composition fluctuation of in and well-width fluctuation in InGaN/GaN multiple quantum wells in light-emitting diode devices. Microsc Microanal 19(S5), 99104.
Ilegems M. & Montgomery H. (1973). Electrical properties of n-type vapor-grown gallium nitride. J Phys Chem Solids 34(5), 885895.
Jarjour A.F., Taylor R.A., Oliver R.A., Kappers M.J., Humphreys C.J. & Tahraoui A. (2007). Cavity-enhanced blue single-photon emission from a single InGaN/GaN quantum dot. Appl Phys Lett 91(5), 052101.
Keller S. & DenBaars S.P. (2003). Metalorganic chemical vapor deposition of group III nitrides—a discussion of critical issues. J Cryst Growth 248, 479486.
Kellogg G. & Tsong T. (1980). Pulsed‐laser atom‐probe field‐ion microscopy. J Appl Phys 51(2), 11841193.
Kelly T.F., Vella A., Bunton J.H., Houard J., Silaeva E.P., Bogdanowicz J. & Vandervorst W. (2014). Laser pulsing of field evaporation in atom probe tomography. Curr Opin Solid State Mater Sci 18(2), 8189.
Kempshall B., Schwarz S., Prenitzer B., Giannuzzi L., Irwin R. & Stevie F. (2001). Ion channeling effects on the focused ion beam milling of Cu. J Vac Sci Technol, B 19(3), 749754.
Kim J., Lochner Z., Ji M.-H., Choi S., Kim H.J., Kim J.S., Dupuis R.D., Fischer A.M., Juday R. & Huang Y. (2014). Origins of unintentional incorporation of gallium in InAlN layers during epitaxial growth, part II: Effects of underlying layers and growth chamber conditions. J Cryst Growth 388, 143149.
Kirchhofer R., Teague M.C. & Gorman B.P. (2013). Thermal effects on mass and spatial resolution during laser pulse atom probe tomography of cerium oxide. J Nucl Mater 436(1), 2328.
Larson D., Foord D., Petford-Long A., Liew H., Blamire M., Cerezo A. & Smith G. (1999). Field-ion specimen preparation using focused ion-beam milling. Ultramicroscopy 79(1), 287293.
Mazumder B., Kaun S.W., Lu J., Keller S., Mishra U.K. & Speck J.S. (2013). Atom probe analysis of AlN interlayers in AlGaN/AlN/GaN heterostructures. Appl Phys Lett 102(11), 111603.
Melmed A., Martinka M., Girvin S., Sakurai T. & Kuk Y. (1981). Analysis of high resistivity semiconductor specimens in an energy‐compensated time‐of‐flight atom probe. Appl Phys Lett 39(5), 416417.
Miller M.K., Cerezo A., Hetherington M. & Smith G. (1996). Atom probe field ion microscopy. Oxford: Clarendon Press.
Moy C.K., Ranzi G., Petersen T.C. & Ringer S.P. (2011). Macroscopic electrical field distribution and field-induced surface stresses of needle-shaped field emitters. Ultramicroscopy 111(6), 397404.
Müller E.W. & Krishnaswamy S. (1974). Energy deficits in pulsed field evaporation and deficit compensated atom‐probe designs. Rev Sci Instrum 45(9), 10531059.
Müller M., Smith G., Gault B. & Grovenor C. (2012). Phase separation in thick InGaN layers – A quantitative, nanoscale study by pulsed laser atom probe tomography. Acta Mater 60(10), 42774285.
Nakamura S., Senoh M., Iwasa N. & Nagahama S.-I. (1995). High-brightness InGaN blue, green and yellow light-emitting diodes with quantum well structures. Jpn J Appl Phys, Part 2 34, L797L799.
Oliver R., Bennett S., Zhu T., Beesley D., Kappers M., Saxey D., Cerezo A. & Humphreys C. (2010). Microstructural origins of localization in InGaN quantum wells. J Phys D: Appl Phys 43(35), 354003.
Prosa T., Clifton P., Zhong H., Tyagi A., Shivaraman R., DenBaars S., Nakamura S. & Speck J. (2011). Atom probe analysis of interfacial abruptness and clustering within a single InxGa1-xN quantum well device on semipolar (10 1 1) GaN substrate. Appl Phys Lett 98(19), 191903.
Prosa T., Olson D., Geiser B., Larson D., Henry K. & Steel E. (2013). Analysis of implanted silicon dopant profiles. Ultramicroscopy 132, 179185.
Rhode S., Horton M., Kappers M., Zhang S., Humphreys C., Dusane R., Sahonta S.-L. & Moram M. (2013). Mg doping affects dislocation core structures in GaN. Phys Rev Lett 111(2), 025502.
Riley J.R., Bernal R.A., Li Q., Espinosa H.D., Wang G.T. & Lauhon L.J. (2012). Atom probe tomography of a-axis GaN nanowires: analysis of nonstoichiometric evaporation behavior. ACS nano 6(5), 38983906.
Riley J.R., Detchprohm T., Wetzel C. & Lauhon L.J. (2014). On the reliable analysis of indium mole fraction within InxGa1-xN quantum wells using atom probe tomography. Appl Phys Lett 104(15), 152102.
Sadler T.C., Kappers M.J. & Oliver R.A. (2011). The effects of varying metal precursor fluxes on the growth of InAlN by metal organic vapour phase epitaxy. J Cryst Growth 314(1), 1320.
Sanford N., Blanchard P., Brubaker M., Bertness K., Roshko A., Schlager J., Kirchhofer R., Diercks D. & Gorman B. (2014). Laser‐assisted atom probe tomography of MBE grown GaN nanowire heterostructures. Physica Status Solidi (c) 11(3–4), 608612.
Saxey D. (2011). Correlated ion analysis and the interpretation of atom probe mass spectra. Ultramicroscopy 111(6), 473479.
Silaeva E.P., Karahka M. & Kreuzer H. (2013). Atom probe tomography and field evaporation of insulators and semiconductors: Theoretical issues. Curr Opin Solid State Mater Sci 17(5), 211216.
Smeeton T., Kappers M., Barnard J., Vickers M. & Humphreys C. (2003). Electron-beam-induced strain within InGaN quantum wells: False indium “cluster” detection in the transmission electron microscope. Appl Phys Lett 83(26), 54195421.
Smith M.D., Taylor E., Sadler T.C., Zubialevich V.Z., Lorenz K., Li H.N., O'Connell J., Alves E., Holmes J. & Martin R. (2014). Determination of Ga auto-incorporation in nominal InAlN epilayers grown by MOCVD. J Mater Chem C 2, 57875792.
Speck J. & Chichibu S. (2009). Nonpolar and semipolar group III nitride-based materials. MRS Bull 34(05), 304312.
Stepień Z.M. & Tsong T.T. (1998). Formation of metal hydride ions in low-temperature field evaporation. Surf Sci 409(1), 5768.
Tamura H., Tsukada M., McKenna K., Shluger A., Ohkubo T. & Hono K. (2012). Laser-assisted field evaporation from insulators triggered by photoinduced hole accumulation. Phys Rev B 86(19), 195430.
Tang F., Gault B., Ringer S.P. & Cairney J.M. (2010). Optimization of pulsed laser atom probe (PLAP) for the analysis of nanocomposite Ti–Si–N films. Ultramicroscopy 110(7), 836843.
Tang F., Gianola D., Moody M., Hemker K. & Cairney J. (2012). Observations of grain boundary impurities in nanocrystalline Al and their influence on microstructural stability and mechanical behaviour. Acta Mater 60(3), 10381047.
Tang F., Zhu T., Oehler F., Fu W.Y., Griffiths J.T., Massabuau F.C.-P., Kappers M.J., Martin T.L., Bagot P.A. & Moody M.P. (2015). Indium clustering in a-plane InGaN quantum wells as evidenced by atom probe tomography. Appl Phys Lett 106(7), 072104.
Thompson K., Gorman B., Larson D., van Leer B. & Hong L. (2006). Minimization of Ga induced FIB damage using low energy clean-up. Microsc Microanal 12(S02), 17361737.
Thompson K., Lawrence D., Larson D., Olson J., Kelly T. & Gorman B. (2007). In situ site-specific specimen preparation for atom probe tomography. Ultramicroscopy 107(2), 131139.
Tsong T. (1984). Formation of multiatomic cluster ions of silicon in pulsed‐laser stimulated field desorption. Appl Phys Lett 45(10), 11491151.
Yao L., Gault B., Cairney J. & Ringer S. (2010). On the multiplicity of field evaporation events in atom probe: a new dimension to the analysis of mass spectra. Philos Mag Lett 90(2), 121129.
Zhu D., Wallis D. & Humphreys C. (2013). Prospects of III-nitride optoelectronics grown on Si. Rep Prog Phys 76(10), 106501.
Zhu J., Fan Y., Zhang H., Lu G., Wang H., Zhao D., Jiang D., Liu Z., Zhang S. & Chen G. (2012). Contribution of GaN template to the unexpected Ga atoms incorporated into AlInN epilayers grown under an indium-very-rich condition by metalorganic chemical vapor deposition (MOCVD). J Cryst Growth 348(1), 2530.
Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Microscopy and Microanalysis
  • ISSN: 1431-9276
  • EISSN: 1435-8115
  • URL: /core/journals/microscopy-and-microanalysis
Please enter your name
Please enter a valid email address
Who would you like to send this to? *
×

Keywords:

Metrics

Full text views

Total number of HTML views: 9
Total number of PDF views: 71 *
Loading metrics...

Abstract views

Total abstract views: 331 *
Loading metrics...

* Views captured on Cambridge Core between September 2016 - 25th November 2017. This data will be updated every 24 hours.