Skip to main content

Surface induced orientation and vertically layered morphology in thin films of poly(3-hexylthiophene) crystallized from the melt

  • Jens Balko (a1), Guiseppe Portale (a2), Ruth H. Lohwasser (a3), Mukundan Thelakkat (a3) and Thomas Thurn-Albrecht (a1)...

The presence of interfaces and geometrical confinement can have a strong influence on the structure and morphology of thin films of semicrystalline polymers. Using surface-sensitive grazing incidence wide angle X-ray scattering and atomic force microscopy to investigate the vertical structure of thin films of poly(3-hexylthiophene) crystallized from the melt, we show that highly oriented crystallites are induced at the air/polymer interface and not as sometimes assumed at the interface to the substrate. These crystallites are oriented with their crystallographic a-axis perpendicular to the plane of the film. While the corresponding orientation dominates in thinner films, for sufficiently thick films (>60 nm) a layer containing unoriented crystals is present below the surface layer. Due to the anisotropic charge transport properties, the observed effects are expected to be of special relevance for potential applications of semiconductor polymers in the field of organic photovoltaics for which vertical transport in thicker films plays an important role.

Corresponding author
a) Address all correspondence to this author. e-mail:
Hide All

Present Address: Fraunhofer Institute for Applied Polymer Research, 14476 Potsdam, Germany


Present Address: BASF, Ludwigshafen, Germany

Contributing Editor: Chris Nicklin

Hide All
1. Liu, Y.X. and Chen, E.Q.: Polymer crystallization of ultrathin films on solid substrates. Coord. Chem. Rev. 254, 10111037 (2010).
2. Li, H.H. and Yan, S.K.: Surface-induced polymer crystallization and the resultant structures and morphologies. Macromolecules 44, 417428 (2011).
3. Carr, J.M., Langhe, D.S., Ponting, M.T., Hiltner, A., and Baer, E.: Confined crystallization in polymer nanolayered films: A review. J. Mater. Res. 27, 13261350 (2012).
4. Frank, C.W., Rao, V., Despotopoulou, M.M., Pease, R.F.W., Hinsberg, W.D., Miller, R.D., and Rabolt, J.F.: Structure in thin and ultrathin spin-cast polymer films. Science 273, 912915 (1996).
5. Ma, Y., Hu, W.B., and Reiter, G.: Lamellar crystal orientations biased by crystallization kinetics in polymer thin films. Macromolecules 39, 51595164 (2006).
6. Löhmann, A.K., Henze, T., and Thurn-Albrecht, T.: Direct observation of prefreezing at the interface melt-solid in polymer crystallization. Proc. Natl. Acad. Sci. U. S. A. 111, 1736817372 (2014).
7. Sear, R.P.: Nucleation: Theory and applications to protein solutions and colloidal suspensions. J. Phys.: Condens. Matter 19, 033101 (2007).
8. Napolitano, S. and Wübbenhorst, M.: Slowing down of the crystallization kinetics in ultrathin polymer films: A size or an interface effect? Macromolecules 39, 59675970 (2006).
9. Napolitano, S. and Wübbenhorst, M.: Deviation from bulk behaviour in the cold crystallization kinetics of ultrathin films of poly(3-hydroxybutyrate). J. Phys.: Condens. Matter 19, 205121 (2007).
10. Vanroy, B., Wübbenhorst, M., and Napolitano, S.: Crystallization of thin polymer layers confined between two adsorbing walls. ACS Macro Lett. 2, 168172 (2013).
11. Martinez-Tong, D.E., Vanroy, B., Wübbenhorst, M., Nogales, A., and Napolitano, S.: Crystallization of poly(L-lactide) confined in ultrathin films: competition between finite size effects and irreversible chain adsorption. Macromolecules 47, 23542360 (2014).
12. Wu, X.Z., Ocko, B.M., Sirota, E.B., Sinha, S.K., Deutsch, M., Cao, B.H., and Kim, M.W.: Surface tension measurements of surface freezing in liquid normal alkanes. Science 261, 10181021 (1993).
13. Ocko, B.M., Wu, X.Z., Sirota, E.B., Sinha, S.K., Gang, O., and Deutsch, M.: Surface freezing in chain molecules: Normal alkanes. Phys. Rev. E: Stat. Phys., Plasmas, Fluids, Relat. Interdiscip. Top. 55, 31643182 (1997).
14. Gautam, K.S. and Dhinojwala, A.: Melting at alkyl side chain comb polymer interfaces. Phys. Rev. Lett. 88, 145501 (2002).
15. Gautam, K.S., Kumar, S., Wermeille, D., Robinson, D., and Dhinojwala, A.: Observation of novel liquid-crystalline phase above the bulk-melting temperature. Phys. Rev. Lett. 90, 215501 (2003).
16. Gang, O., Wu, X.Z., Ocko, B.M., Sirota, E.B., and Deutsch, M.: Surface freezing in chain molecules. II. Neat and hydrated alcohols. Phys. Rev. E: Stat. Phys., Plasmas, Fluids, Relat. Interdiscip. Top. 58, 60866100 (1998).
17. Prasad, S., Jiang, Z., Sinha, S.K., and Dhinojwala, A.: Partial crystallinity in alkyl side chain polymers dictates surface freezing. Phys. Rev. Lett. 101, 065505 (2008).
18. Jeon, Y., Vaknin, D., Bu, W., Sung, J., Ouchi, Y., Sung, W., and Kim, D.: Surface nanocrystallization of an ionic liquid. Phys. Rev. Lett. 108, 055502 (2012).
19. Sirringhaus, H., Brown, P.J., Friend, R.H., Nielsen, M.M., Bechgaard, K., Langeveld-Voss, B.M.W., Spiering, A.J.H., Janssen, R.A.J., Meijer, E.W., Herwig, P., and de Leeuw, D.M.: Two-dimensional charge transport in self-organized, high-mobility conjugated polymers. Nature 401, 685688 (1999).
20. Sirringhaus, H., Tessler, N., and Friend, R.H.: Integrated optoelectronic devices based on conjugated polymers. Science 280, 17411744 (1998).
21. Forrest, S.R.: The path to ubiquitous and low-cost organic electronic appliances on plastic. Nature 428, 911918 (2004).
22. Li, G., Shrotriya, V., Huang, J.S., Yao, Y., Moriarty, T., Emery, K., and Yang, Y.: High-efficiency solution processable polymer photovoltaic cells by self-organization of polymer blends. Nat. Mater. 4, 864868 (2005).
23. Salleo, A.: Charge transport in polymeric transistors. Mater. Today 10, 3845 (2007).
24. Bao, Z., Dodabalapur, A., and Lovinger, A.J.: Soluble and processable regioregular poly(3-hexylthiophene) for thin film field-effect transistor applications with high mobility. Appl. Phys. Lett. 69, 41084110 (1996).
25. Müller-Buschbaum, P.: The active layer morphology of organic solar cells probed with grazing incidence scattering techniques. Adv. Mater. 26, 76927709 (2014).
26. Hugger, S., Thomann, R., Heinzel, T., and Thurn-Albrecht, T.: Semicrystalline morphology in thin films of poly(3-hexylthiophene). Colloid Polym. Sci. 282, 932938 (2004).
27. Wu, Z.Y., Petzold, A., Henze, T., Thurn-Albrecht, T., Lohwasser, R.H., Sommer, M., and Thelakkat, M.: Temperature, and molecular weight dependent hierarchical equilibrium structures in semiconducting poly(3-hexylthiophene). Macromolecules 43, 46464653 (2010).
28. Brinkmann, M. and Rannou, P.: Effect of molecular weight on the structure and morphology of oriented thin films of regioregular poly(3-hexylthiophene) grown by directional epitaxial solidification. Adv. Funct. Mater. 17, 101108 (2007).
29. Prosa, T.J., Winokur, M.J., Moulton, J., Smith, P., and Heeger, A.J.: X-ray structural studies of poly(3-alkylthiophenes)—an example of an inverse comb. Macromolecules 25, 43644372 (1992).
30. Tashiro, K., Kobayashi, M., Kawai, T., and Yoshino, K.: Crystal structural change in poly(3-alkyl thiophene)s induced by iodine doping as studied by an organized combination of X-ray diffraction, infrared/Raman spectroscopy and computer simulation techniques. Polymer 38, 28672879 (1997).
31. Joshi, S., Grigorian, S., Pietsch, U., Pingel, P., Zen, A., Neher, D., and Scherf, U.: Thickness dependence of the crystalline structure and hole mobility in thin films of low molecular weight poly(3-hexylthiophene). Macromolecules 41, 68006808 (2008).
32. Kline, R.J., Mcgehee, M.D., Kadnikova, E.N., Liu, J.S., and Frechet, J.M.J.: Controlling the field-effect mobility of regioregular polythiophene by changing the molecular weight. Adv. Mater. 15, 15191522 (2003).
33. Zen, A., Saphiannikova, M., Neher, D., Grenzer, J., Grigorian, S., Pietsch, U., Asawapirom, U., Janietz, S., Scherf, U., Lieberwirth, I., and Wegner, G.: Effect of molecular weight on the structure and crystallinity of poly(3-hexylthiophene). Macromolecules 39, 21622171 (2006).
34. Ballantyne, A.M., Chen, L., Dane, J., Hammant, T., Braun, F.M., Heeney, M., Duffy, W., McCulloch, I., Bradley, D.D.C., and Nelson, J.: The effect of poly(3-hexylthiophene) molecular weight on charge transport and the performance of polymer: Fullerene solar cells. Adv. Funct. Mater. 18, 23732380 (2008).
35. Kim, Y., Cook, S., Tuladhar, S.M., Choulis, S.A., Nelson, J., Durrant, J.R., Bradley, D.D.C., Giles, M., McCulloch, I., Ha, C.S., and Ree, M.: A strong regioregularity effect in self-organizing conjugated polymer films and high-efficiency polythiophene: Fullerene solar cells. Nat. Mater. 5, 197203 (2006).
36. Brinkmann, M.: Structure, and morphology control in thin films of regioregular poly(3-hexylthiophene). J. Polym. Sci., Part B: Polym. Phys. 49, 12181233 (2011).
37. Schulz, G.L. and Ludwigs, S.: Controlled crystallization of conjugated polymer films from solution and solvent vapor for polymer electronics. Adv. Funct. Mater. 27, 1603083 (2017).
38. Virkar, A.A., Mannsfeld, S., Bao, Z.A., and Stingelin, N.: Organic semiconductor growth, and morphology considerations for organic thin-film transistors. Adv. Mater. 22, 38573875 (2010).
39. Boudouris, B.W., Ho, V., Jimison, L.H., Toney, M.F., Salleo, A., and Segalman, R.A.: Real-time observation of poly(3-alkylthiophene) crystallization and correlation with transient optoelectronic properties. Macromolecules 44, 66536658 (2011).
40. Woo, C.H., Piliego, C., Holcombe, T.W., Toney, M.F., and Frechet, J.M.J.: A quantitative correlation between the mobility and crystallinity of photo-cross-linkable P3HT. Macromolecules 45, 30573062 (2012).
41. Singh, C.R., Gupta, G., Lohwasser, R., Engmann, S., Balko, J., Thelakkat, M., Thurn-Albrecht, T., and Hoppe, H.: Correlation of charge transport with structural order in highly ordered melt-crystallized poly(3-hexylthiophene) thin films. J. Polym. Sci., Part B: Polym. Phys. 51, 943951 (2013).
42. Factor, B.J., Russell, T.P., and Toney, M.F.: Grazing-incidence X-ray-scattering studies of thin-films of an aromatic polyimide. Macromolecules 26, 28472859 (1993).
43. Kawamoto, N., Mori, H., Nitta, K.H., Sasaki, S., Yui, N., and Terano, M.: Microstructural characterization of polypropene surfaces using grazing incidence X-ray diffraction. Macromol. Chem. Phys. 199, 261266 (1998).
44. Jukes, P.C., Das, A., Durell, M., Trolley, D., Higgins, A.M., Geoghegan, M., Macdonald, J.E., Jones, R.A.L., Brown, S., and Thompson, P.: Kinetics of surface crystallization in thin films of poly(ethylene terephthalate). Macromolecules 38, 23152320 (2005).
45. Yakabe, H., Tanaka, K., Nagamura, T., Sasaki, S., Sakata, O., Takahara, A., and Kajiyama, T.: Grazing incidence X-ray diffraction study on surface crystal structure of polyethylene thin films. Polym. Bull. 53, 213222 (2005).
46. Kline, R.J., Mcgehee, M.D., and Toney, M.F.: Highly oriented crystals at the buried interface in polythiophene thin-film transistors. Nat. Mater. 5, 222228 (2006).
47. Baker, J.L., Jimison, L.H., Mannsfeld, S., Volkman, S., Yin, S., Subramanian, V., Salleo, A., Alivisatos, A.P., and Toney, M.F.: Quantification of thin film crystallographic orientation using X-ray diffraction with an area detector. Langmuir 26, 91469151 (2010).
48. Jimison, L.H., Himmelberger, S., Duong, D.T., Rivnay, J., Toney, M.F., and Salleo, A.: Vertical confinement and interface effects on the microstructure and charge transport of P3HT thin films. J. Polym. Sci., Part B: Polym. Phys. 51, 611620 (2013).
49. Skrypnychuk, V., Boulanger, N., Yu, V., Hilke, M., Mannsfeld, S.C.B., Toney, M.F., and Barbero, D.R.: Enhanced vertical charge transport in a semiconducting P3HT thin film on single layer graphene. Adv. Funct. Mater. 25, 664670 (2015).
50. Schmidt-Hansberg, B., Sanyal, M., Klein, M.F.G., Pfaff, M., Schnabel, N., Jaiser, S., Vorobiev, A., Müller, E., Colsmann, A., Scharfer, P., Gerthsen, D., Lemmer, U., Barrena, E., and Schabel, W.: Moving through the phase diagram: Morphology formation in solution cast polymer–fullerene blend films for organic solar cells. ACS Nano 5, 85798590 (2011).
51. Kim, D.H., Jang, Y., Park, Y.D., and Cho, K.: Layered molecular ordering of self-organized poly(3-hexylthiophene) thin films on hydrophobized surfaces. Macromolecules 39, 58435847 (2006).
52. Choi, D., Jin, S., Lee, Y., Kim, S.H., Chung, D.S., Hong, K., Yang, C., Jung, J., Kim, J.K., Ree, M., and Park, C.E.: Direct observation of interfacial morphology in poly(3-hexylthiophene) transistors: Relationship between grain boundary and field-effect mobility. ACS Appl. Mater. Interfaces 2, 4853 (2010).
53. Anglin, T.C., Speros, J.C., and Massari, A.M.: Interfacial ring orientation in polythiophene field-effect transistors on functionalized dielectrics. J. Phys. Chem. C 115, 1602716036 (2011).
54. Anglin, T.C., Lane, A.P., and Massari, A.M.: Real-time structural evolution at the interface of an organic transistor during thermal annealing. J. Mater. Chem. C 2, 33903400 (2014).
55. Huang, B.Y., Glynos, E., Frieberg, B., Yang, H.X., and Green, P.F.: Effect of thickness-dependent microstructure on the out-of-plane hole mobility in poly(3-hexylthiophene) films. ACS Appl. Mater. Interfaces 4, 52045210 (2012).
56. Yimer, Y.Y., Dhinojwala, A., and Tsige, M.: Interfacial properties of free-standing poly(3-hexylthiophene) films. J. Chem. Phys. 137, 044703 (2012).
57. Balko, J., Rinscheid, A., Wurm, A., Schick, C., Lohwasser, R.H., Thelakkat, M., and Thurn-Albrecht, T.: Crystallinity of poly(3-hexylthiophene) in thin films determined by fast scanning calorimetry. J. Polym. Sci., Part B: Polym. Phys. 54, 17911801 (2016).
58. Breiby, D.W., Bunk, O., Andreasen, J.W., Lemke, H.T., and Nielsen, M.M.: Simulating X-ray diffraction of textured films. J. Appl. Crystallogr. 41, 262271 (2008).
59. Dosch, H., Batterman, B.W., and Wack, D.C.: Depth-controlled grazing-incidence diffraction of synchrotron X radiation. Phys. Rev. Lett. 56, 11441147 (1986).
60. Tolan, M.: X-ray Scattering From Soft-matter Thin Films, Vol. 148 (Springer-Verlag, Berlin-Heidelberg, 1999).
61. A. Hammersley: Fit2D. (accessed September 09, 2015).
62. Scherrer, P.: Bestimmung der Größe und der inneren Struktur von Kolloidteilchen mittels Röntgenstrahlen. Nachrichten von der Gesellschaft der Wissenschaften zu Göttingen 1918, 98100 (1918).
63. Langford, J.I. and Wilson, A.J.C.: Scherrer after sixty years: A survey and some new results in the determination of crystallite size. J. Appl. Crystallogr. 11, 102113 (1978).
64. Holzwarth, U. and Gibson, N.: The Scherrer equation versus the ‘Debye-Scherrer equation’. Nat. Nanotechnol. 6, 534 (2011).
65. Sheina, E.E., Liu, J.S., Iovu, M.C., Laird, D.W., and McCullough, R.D.: Chain growth mechanism for regioregular nickel-initiated cross-coupling polymerizations. Macromolecules 37, 35263528 (2004).
66. Balko, J., Lohwasser, R.H., Sommer, M., Thelakkat, M., and Thurn-Albrecht, T.: Determination of the crystallinity of semicrystalline poly(3-hexylthiophene) by means of wide-angle X-ray scattering. Macromolecules 46, 96429651 (2013).
67. French, P.J., Sarro, P.M., Mallee, R., Fakkeldij, E.J.M., and Wolffenbuttel, R.F.: Optimization of a low-stress silicon nitride process for surface-micromachining applications. Sens. Actuators, A 58, 149157 (1997).
68. Aiyama, T., Fukunaga, T., Niihara, K., Hirai, T., and Suzuki, K.: An X-ray diffraction study of the amorphous structure of chemically vapor-deposited silicon nitride. J. Non-Cryst. Solids 33, 131139 (1979).
69. Crossland, E.J.W., Rahimi, K., Reiter, G., Steiner, U., and Ludwigs, S.: Systematic control of nucleation density in poly(3-hexylthiophene) thin films. Adv. Funct. Mater. 21, 518524 (2011).
70. Kohn, P., Rong, Z.X., Scherer, K.H., Sepe, A., Sommer, M., Müller-Buschbaum, P., Friend, R.H., Steiner, U., and Hüttner, S.: Crystallization-induced 10-nm structure formation in P3HT/PCBM blends. Macromolecules 46, 40024013 (2013).
71. Koch, F.P.V., Rivnay, J., Foster, S., Müller, C., Downing, J.M., Buchaca-Domingo, E., Westacott, P., Yu, L.Y., Yuan, M.J., Baklar, M., Fei, Z.P., Luscombe, C., McLachlan, M.A., Heeney, M., Rumbles, G., Silva, C., Salleo, A., Nelson, J., Smith, P., and Stingelin, N.: The impact of molecular weight on microstructure and charge transport in semicrystalline polymer semiconductors—poly(3-hexylthiophene), a model study. Prog. Polym. Sci. 38, 19781989 (2013).
72. Kayunkid, N., Uttiya, S., and Brinkmann, M.: Structural model of regioregular poly(3-hexylthiophene) obtained by electron diffraction analysis. Macromolecules 43, 49614967 (2010).
73. Werzer, O. and Resel, R.: Model-independent X-ray reflectivity fitting for structure analysis of poly(3-hexylthiophene) films. Macromolecules 46, 35293533 (2013).
74. Yimer, Y.Y. and Tsige, M.: Static and dynamic properties of poly(3-hexylthiophene) films at liquid/vacuum interfaces. J. Chem. Phys. 137, 204701 (2012).
75. Koch, F.P.V., Heeney, M., and Smith, P.: Thermal, and structural characteristics: Of oligo(3-hexylthiophene)s (3HT) n , n = 4–36. J. Am. Chem. Soc. 135, 1369913709 (2013).
76. Gurau, M.C., Delongchamp, D.M., Vogel, B.M., Lin, E.K., Fischer, D.A., Sambasivan, S., and Richter, L.J.: Measuring molecular order in poly(3-alkylthiophene) thin films with polarizing spectroscopies. Langmuir 23, 834842 (2007).
77. Oosterbaan, W.D., Bolsee, J.C., Gadisa, A., Vrindts, V., Bertho, S., D’Haen, J., Cleij, T.J., Lutsen, L., McNeill, C.R., Thomsen, L., Manca, J.V., and Vanderzande, D.: Alkyl-chain-length-independent hole mobility via morphological control with poly(3-alkylthiophene) nanofibers. Adv. Funct. Mater. 20, 792802 (2010).
Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Journal of Materials Research
  • ISSN: 0884-2914
  • EISSN: 2044-5326
  • URL: /core/journals/journal-of-materials-research
Please enter your name
Please enter a valid email address
Who would you like to send this to? *


Type Description Title
Supplementary materials

Balko supplementary material
Balko supplementary material 1

 PDF (743 KB)
743 KB


Full text views

Total number of HTML views: 67
Total number of PDF views: 157 *
Loading metrics...

Abstract views

Total abstract views: 797 *
Loading metrics...

* Views captured on Cambridge Core between 11th April 2017 - 16th July 2018. This data will be updated every 24 hours.