Hostname: page-component-7dd5485656-6kn8j Total loading time: 0 Render date: 2025-10-31T11:54:02.516Z Has data issue: false hasContentIssue false
  • English
  • Français

An Approach to Quantitative Image Analysis for Cement Pastes

Published online by Cambridge University Press:  21 February 2011

Yuting Wang  and
Sidney Diamond
Yuting Wang
Affiliation:
School of Civil Engineering, Purdue University, West Lafayette, IN47907
Sidney Diamond
Affiliation:
School of Civil Engineering, Purdue University, West Lafayette, IN47907
Get access

Abstract

Cement paste microstructure as revealed in backscatter SEM presents a number of inherent difficulties that interfere with implementing quantitative image analysis. An approach to overcoming these difficulties is presented, involving gray scale segmentation coupled with application of a hole filling algorithm. Using this approach it is possible to isolate the unhydrated and hydrated portions of phenograins separately, and to combine them for analysis of combined phenograins. Pores and coarse calcium hydroxide masses may also be isolated for feature analysis. Results are reported on mature cement pastes prepared at two water:cement ratios (w:c 0.45 and w:c 0.30) and with and without superplasticizer. It was found that superplasticizer greatly reduced the content and the average size of “visible pores” and increased the content and the average size of coarse CH particles compared to corresponding plain pastes. The area per hydrated phenograin was much smaller in the lower w:c ratio pastes and higher in superplasticized pastes. Among the solid features measured, unhydrated cement particles had the smallest circularity values (at about 2.7) and were the most circular features; Hydrated phenograins had the largest circularity values (at 3.5) and were the most elongated features.

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

Article purchase

Temporarily unavailable

References

1. Scrivener, K. L., Patel, H. H., Pratt, P. L., and Parrot, L. J., in Microstructural Development during Hydration of Cement, edited by Struble, L. J. and Brown, P. W. (Mater. Res. Soc. Proc. 85, Boston, MA, 1986) pp.67–76.Google Scholar
2. Zhao, H. and Darwin, D., Cem. and Concr. Res. 22, 695 (1992).Google Scholar
3. Kjellsen, K. O., Detwiler, R. J., and Gjorv, O. E., Cem Concr. Res. 20. 308 (1990); 20, 929 (1990).Google Scholar
4. Saada, R., Ringot, E., and Barrioulet, M., Cem. Concr. Res. 21, 1058 (1991).Google Scholar
5. Scrivener, K. L., Cem. Concr. Res. 22, 1224 (1992).Google Scholar
6. Diamond, S. and Bonen, D., J. Amer. Ceram. Soc. 76, 2993 (1993).Google Scholar
7. Diamond, S. and Leeman, M. E., This Symposium.Google Scholar