Hostname: page-component-848d4c4894-75dct Total loading time: 0 Render date: 2024-05-21T10:45:49.907Z Has data issue: false hasContentIssue false

Energetics and Kinetics of Epitaxial Island Formation on Lattice Mismatched Patterned Substrates

Published online by Cambridge University Press:  01 February 2011

Noah D. Machtay
Affiliation:
Department of Mechanical Engineering, State University of New York Stony Brook, Stony Brook, NY 11794–2300, U.S.A.
Robert V. Kukta
Affiliation:
Department of Mechanical Engineering, State University of New York Stony Brook, Stony Brook, NY 11794–2300, U.S.A.
Get access

Abstract

Spontaneous self-assembly of nanostructures has been a problem of long-standing interest for fabricating advanced electrical and optical devices. One approach towards controlled self-assembly is epitaxial growth on topographically patterned substrates, where surface features act as preferred sites for island formation. The substrate shape addressed here is a periodic array of rectangular mesas. Strained-layer growth on such substrates has been observed to form as islands on the edge, in the center, or at a combination of those locations on the top of the mesa. The purpose of this investigation is to discern whether these morphologies are driven by energetic or kinetic mechanisms. An energetic analysis is done under the assumption that the system free energy consists of surface free energy and strain energy. Strain arises due to a lattice mismatch between the film and substrate materials. The film and substrate are treated as two-dimensional linearly elastic solids with similar elastic properties. Under the constraint of fixed volume, various island arrangements and shapes are compared to determine low energy configurations. Islands are assumed to have the shape of a circular arc, and island positions at the center of the mesa and on the mesa edges are considered for one, two, and three island systems. For symmetric configurations, depending on mismatch strain, surface energy, volume, and relative substrate dimensions, it is found that either the configuration with a single centered island or the configuration with two edge mounted islands may be favored. Allowing for asymmetry, a single island placed on one edge of the substrate mesa is generally the low energy configuration. This occurs because islands located near the edge of a raised mesa are most efficient at relaxing mismatch strain due to an increased compliance. Kinetic simulations of morphological evolution during combined deposition and surface diffusion are also conducted in order to identify possible metastable or slowly evolving non-equilibrium states.

Type
Research Article
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Kitajima, T., Liu, B., and Leone, S. R.. Appl. Phys. Lett, 80(3):497, 2002 Google Scholar
2. Jin, G., Liu, J. L., Thomas, S. G., Luo, Y. H., Wang, K. L., and Nguyen, B. Y.. Appl. Phys. Lett, 75(18):2752, 1999.Google Scholar
3. Lee, H.-M., Yang, T.-H., Luo, G., and Chang, E. Y.. Jpn. J. Appl. Phys., 42:L718, 2003.Google Scholar
4. Zhong, Z., Halilovic, A., Muhlberger, M., Schaffler, F., and Bauer, G.. J. Appl. Phys., 93:6258, 2003.Google Scholar
5. Zhong, Z., Halilovic, A., Muhlberger, M., Schaffler, F., and Bauer, G.. Appl. Phys. Lett., 82:445, 2003.Google Scholar
6. Johnson, H. T. and Freund, L. B.. J. Appl. Phys., 81:6081, 1997.Google Scholar
7. Spencer, B. J. and Tersoff, J.. In Zangwill, A. et al., editor, Evolution of Epitaxial Structure and Morpholgy, volume 399, page 283. Mater. Res. Soc. Proc., Pittsburgh, 1996.Google Scholar
8. Kukta, R. V. and Freund, L. B.. J. Mech. Phys. Solids, 11/12:1835, 1997.Google Scholar
9. Kukta, R. V. and Kouris, D.. J. Appl. Phys, submitted, 2004.Google Scholar