Hostname: page-component-848d4c4894-p2v8j Total loading time: 0.001 Render date: 2024-05-14T13:31:26.839Z Has data issue: false hasContentIssue false
  • English
  • Français

Non-equilibrium defects in aluminum-doped zinc oxide thin films grown with a pulsed laser deposition method

Published online by Cambridge University Press:  03 March 2011

Haruki Ryoken ,
Isao Sakaguchi ,
Naoki Ohashi ,
Takashi Sekiguchi ,
Shunichi Hishita  and
Hajime Haneda
Haruki Ryoken
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044 Japan; and Department of Applied Science for Electronics & Materials, Kyushu University, Kasuga, Fukuoka 816-8580, Japan
Isao Sakaguchi
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044, Japan
Naoki Ohashi*
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044, Japan
Takashi Sekiguchi
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044, Japan
Shunichi Hishita
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044, Japan
Hajime Haneda
Affiliation:
National Institute for Materials Science, Tsukuba, Ibaraki 305-0044 Japan; and Department of Applied Science for Electronics & Materials, Kyushu University, Kasuga, Fukuoka 816-8580, Japan
*
a)Address all correspondence to this author. e-mail: OHASHI.Naoki@nims.go.jp
Get access

Abstract

Zinc oxide (ZnO) films doped with aluminum (Al) were deposited with a pulsed laser deposition technique to characterize the charge compensation phenomena in ZnO. In particular, oxygen radical (O*) irradiation during film deposition was used to modify the oxygen stoichiometry. Irradiation with O* decreased electron concentration in Al-doped ZnO. The lattice parameter of the resultant films also varied with the growth conditions. However, no obvious correlation between electron concentration and lattice parameter was found. The self-diffusion coefficients indicated the presence of non-equilibrium defects. The properties of the films are discussed from the viewpoint of non-equilibrium compensated defects detected in the diffusion measurements.

Keywords

DefectsPulsed laser deposition (PLD)Thin film
Type
Articles
Information
Journal of Materials Research , Volume 20 , Issue 10 , October 2005 , pp. 2866 - 2872
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Ohta, H., Kawamura, K., Orita, M., Hirano, M., Sarukura, N. and Hosono, H.: Current injection emission from a transparent p-n junction composed of p-SrCu2O2/n-ZnO. Appl. Phys. Lett. 77, 475 (2000).CrossRefGoogle Scholar
2Hoffman, R.L., Norris, B.J. and Wager, J.F.: ZnO-based transparent thin-film transistors. Appl. Phys. Lett. 82, 733 (2003).CrossRefGoogle Scholar
3Tsukazaki, A., Ohtomo, A., Onuma, T., Ohtani, M., Makino, T., Sumiya, M., Ohtani, K., Chichibu, S.F., Fuke, S., Segawa, Y., Ohno, H., Koinuma, H. and Kawasaki, M.: Repeated temperature modulation epitaxy for p-type doping and light-emitting diode based on ZnO. Nat. Mater. 4, 42 (2005).CrossRefGoogle Scholar
4Neumann, G.: Current Topics in Materials Science, edited by Kaldis, E. (North-Holland Publishing Company, 1981), Chap. 7, p. 269.Google Scholar
5Minami, T.: New n-type transparent conducting oxides. MRS Bull. 25, 38 (2000).CrossRefGoogle Scholar
6Ohashi, N., Ogino, T., Sakaguchi, I., Hishit, S., Komatsu, M., Takenaka, T. and Haneda, H.: Fabrication of epitaxial In2O3(ZnO)5 thin films by RF sputtering and their characterization by x-ray and electron diffraction techniques. J. Cryst. Growth 237–239, 558 (2002).CrossRefGoogle Scholar
7Ohashi, N., Ebisawa, N., Sekiguchi, T., Sakaguchi, I., Wada, Y., Takenaka, T. and Haneda, H.: Yellowish-white luminescence in codoped ZnO. Appl. Phys. Lett. 86, 091902-1 (2005).CrossRefGoogle Scholar
8Ohashi, N., Tanaka, J., Ohgaki, T., Haneda, H., Ozawa, M. and Tsurumi, T.: Isothermal capacitance transient spectroscopy for deep levels in Co- and Mn-doped ZnO single crystals. J. Mater. Res. 17, 1529 (2002).CrossRefGoogle Scholar
9Haneda, H., Sakaguchi, I., Hishita, S., Ishigaki, T. and Mitsuhashi, T.: Oxygen metastable defects in calcium titanate thin films. J. Therm. Anal. Calorim. 60, 675 (2000).CrossRefGoogle Scholar
10Itoh, J., Haneda, H., Hishita, S., Sakaguchi, I., Ohashi, N. and Yashima, I.: Diffusion and solubility of holmium ions in barium titanate ceramics. J. Mater. Res. 19, 3512 (2004).CrossRefGoogle Scholar
11Nakahara, K., Tanabe, T., Takasu, H., Fons, P., Iwata, K., Yamada, A., Matsubara, K., Hunger, R. and Niki, S.: Growth of undoped ZnO films with improved electrical properties by radical source molecular beam epitaxy. Jpn. J. Appl. Phys. 40, 250 (2001).CrossRefGoogle Scholar
12Oishi, Y. and Kingery, W.D.: Self-diffusion of oxygen in single crystal and polycrystalline aluminum oxide. J. Chem. Phys. 33, 480 (1960).CrossRefGoogle Scholar
13Madelung, O., Schulz, M. and Weiss, H.: Technology, Vol. 17 (Springer-Verlag, Berlin, Germany, 1982).Google Scholar
14Islam, M.N., Ghosh, T.B., Chopra, K.L. and Acharya, H.N.: XPS and x-ray diffraction studies of aluminum-doped zinc oxide transparent conducting films. Thin Solid Films 280, 20 (1996).CrossRefGoogle Scholar
15Tsurumi, T., Nishizawa, S., Ohashi, N. and Ohgaki, T.: Electric properties of zinc oxide epitaxial films grown by ion-beam sputtering with oxygen-radical irradiation. Jpn. J. Appl. Phys. 38, 3682 (1999).CrossRefGoogle Scholar
16Kolb, D.M. and Schulz, H-J.: Current Topics in Materials Science, Vol. 7, edited by Kaldis, E. (North-Holland Publishing Co., Amsterdam, The Netherlands, 1981), p. 226.Google Scholar
17Ohgaki, T., Kawamura, Y., Ohashi, N., Adachi, Y., Tsurumi, T., Minami, F. and Haneda, H.: Optical properties of heavily aluminum-doped zinc oxide thin films prepared by molecular beam epitaxy. Key Eng. Mater. 248, 91 (2003).CrossRefGoogle Scholar
18Kohan, A.F., Ceder, G., Morgan, D. and Van Walle, C.G. de: First-principles study of native point defects in ZnO. Phys. Rev. B 61, 15019 (2000).CrossRefGoogle Scholar
19Oba, F., Nishitani, S.R., Isotani, S., Adachi, H. and Tanaka, I.: Energetics of native defects in ZnO. J. Appl. Phys. 90, 824 (2001).CrossRefGoogle Scholar
20Crank, J.: The Mathematics of Diffusion (Oxford University Press, Oxford, U.K., 1975), p. 30 .Google Scholar
21Ryoken, H., Sakaguchi, I., Ohgaki, T., Adachi, Y., Takenaka, T., Ohashi, N. and Haneda, H.: Oxygen diffusion in Zinc oxide thin films deposited by PLD method. J. Jpn. Soc. Pow. Pow. Metall. 51, 852 2004 , in Japanese.CrossRefGoogle Scholar
22Hallwig, D. and Sockel, H.G.: Reactivity of Solids (Plenum, New York, 1977), p. 631 .CrossRefGoogle Scholar
23Haneda, H., Tanaka, J., Hishita, S., Ohgaki, T. and Ohashi, N.: Oxygen diffusion in zinc oxide single crystals. Key Eng. Mater. 157–158, 221 (1998).CrossRefGoogle Scholar
24Haneda, H., Sakaguchi, I., Watanabe, A., Ishigaki, T. and Tanaka, J.: Oxygen diffusion in single- and poly-crystalline zinc oxides. J. Electroceram. 4, 41 (1999).CrossRefGoogle Scholar
25Ryoken, H., Sakaguchi, I., Ohgaki, T., Ohashi, N., Adachi, Y. and Haneda, H.: Defect structures in undoped and doped ZnO films studied by solid state diffusion, in Progress in Compound Semiconductor Materials IV—Electronics and Optoelectronics Applications, edited by Brown, G.J., Biefeld, R.M., Gmachl, C., Manasreh, M.O., and Unterrainer, K. (Mater. Res. Soc. Symp. Proc. 829, Warrendale, PA, 2005), p. 145.Google Scholar