Introduction
In 2019, Florida produced 60% and 45% of the total U.S. value for fresh market tomatoes and bell peppers, respectively (USDA-NASS 2020). Most of these crops were grown using a plasticulture production system (Boyd and Schumann Reference Boyd and Schumann2018). Plastic mulch has many benefits including effective weed suppression in the crop row (Lamont Reference Lamont and Orzolek2017; Tarrant et al. Reference Tarrant, Brainard and Hayden2020). However, broadleaf and grass weeds still germinate and emerge in the transplant holes (Garvey et al. Reference Garvey, Meyers and Monks2013). This proximity of the weeds to the crop maximizes the weed-crop competition, and in turn, crop growth and development can also be influenced (Monks and Oliver Reference Monks and Oliver1988; Pike et al. Reference Pike, Stoller and Wax1990).
Herbicides applied preemergence (PRE) and a limited number of postemergent (POST) herbicides are registered for use on vegetable crops and are used for weed management. PRE herbicides are typically broadcast applied over the bed top prior to laying the plastic mulch, which results in the application of herbicides where there are no transplant holes, and subsequently, where weeds cannot emerge. The application of herbicides only where the plastic is punctured would be a preferred approach because it would reduce overall herbicide use. Boyd and Schumann (Reference Boyd and Schumann2018) developed a hole-punch applicator that takes this approach and applies herbicides only where the plastic is punctured during the hole-punch operation. Their approach reduced PRE herbicide use by 88% to 92% compared to conventional banded applications. However, with both methods the soil is disturbed during the transplant operation, and as a result, weed control is likely to be reduced.
Previous research has shown that PRE herbicides when applied on the bed top prior to the plastic mulch being applied usually provide effective suppression of weeds during the early season, but do not provide season-long control (Yu et al. Reference Yu, Sharpe and Boyd2019). Herbicide application following transplant establishment should improve weed control in the planting holes. Yu et al. (Reference Yu, Boyd, Schumann and Sharpe2021) reported tomato tolerance from fomesafen, S-metolachlor, metribuzin, and oxyfluorfen on different carrier volumes when applied in narrow bands over the planting holes 2 wk after transplant with no significant tomato injury stunting or yield reduction. Ackley et al. (Reference Ackley, Wilson and Hines1997) also observed that metribuzin and rimsulfuron applied 10 wk after transplant did not affect the final tomato yield and still observed reasonable weed control.
We conclude that posttransplant PRE herbicide applications may be safe for use with pepper and tomato crops and provide desirable weed control while at the same time substantially reducing herbicide inputs. We also believe that smart spray technology developed at the University of Florida (Boyd and Schumann, Reference Boyd and Schumann2018) could be used to accomplish this goal. The first step is to identify safe herbicide options for both crops. Consequently, the objectives of this research were to 1) evaluate tomato and bell pepper tolerance to PRE herbicides applied 2 wk posttransplant, and 2) evaluate weed control with the posttransplant herbicides.
Material and methods
Experimental Site
Four field research trials were conducted at the Gulf Coast Research and Education Center (GCREC) in Balm, FL (27.76°N, 82.22°W). The soil at the research site is a Myakka fine sand (sandy, siliceous hyperthermic Oxyaqui Alorthod), pH 6.5, and with 1.2% organic matter. Raised beds were shaped and formed with bed pressing equipment (Kennco Manufacturing, Ruskin, FL). The dimension of the raised beds was 30.5 cm tall and 66 cm wide on the top with 1.5 m between beds. The beds were formed and fumigated with 225 kg ha−1 of 1,3 dichloropropene+chloropicrin (Pic-Clor 60; Soil Chemicals Corporation D/B/A Cardinal Professional Products, Hollister, CA). Immediately following fumigation the beds were covered with virtually impermeable film (thickness = 1.25 mm; Berry Plastics Corp., Evansville, IN) with double-drip-tape buried at 2.5 cm beneath the soil surface in the middle of each bed.
The experimental design was a randomized complete block design with four replications. The herbicides evaluated for both crops were halosulfuron, S-metolachlor, metribuzin, fomesafen, and pendimethalin, with a nontreated control (Table 1). These herbicides were chosen for use on both tomato and pepper with all products registered as PRE herbicides for tomato. Even though the PRE herbicides metribuzin and fomesafen are not registered for use on pepper crops, we opted to evaluate them for potential use.
Herbicide product, application rate, and manufacturer information.
At 2 wk after transplant (WATP), herbicides were applied to planting holes with a CO2-pressurized backpack sprayer to simulate the hole punch applicator previous reported by Boyd and Schumann (Reference Boyd and Schumann2018). The average hole size was 0.79 cm by 0.79 cm. The hole-punch applicator was not used because the current version is designed for use pretransplant. The sprayer was calibrated to deliver a carrier volume of 187 L ha−1 at 241 kPa with a boom equipped with a single 8002EVS flat-fan nozzle (Teejet Spraying Systems Co., Roswell, GA). The spray was directed at the base of the transplant and positioned to ensure the spray covered the transplant hole and provided a consistent application rate.
Tomato and Pepper Tolerance of PRE Herbicides Applied on the Planting Holes
Tomato (cv ‘Winter Haven’) experiments were conducted in 2018 with Trial I conducted in spring, and Trial II in the fall. The raised beds were formed and fumigated on January 29, 2018, and July 13, 2018, in Trial I and II, respectively, as previously described. The plot was a single 22.8-m raised bed. Tomato plants were spaced 60 cm between plants, and were transplanted on March 7, 2018, and August 15, 2018, in a single row per bed in Trials I and II, respectively.
For Pepper (cv ‘Aristotle’) two experiments were also conducted, where Trial I was conducted in fall 2018 and Trial II in spring 2019. The raised beds were formed and fumigated with previously described fumigants on July 11, 2018, and January 25, 2019, in Trial I and Trial II, respectively. The plot was a single 22.8-m raised bed. Pepper plants were spaced 38 cm apart and were transplanted in a double row per bed on August 15, 2018 (Trial I), and March 12, 2019 (Trial II).
The weather conditions, including average, minimum, and maximum air temperature in the spring and fall were similar throughout the experimental period for both crops, though monthly averages increased from the beginning to the end of the experiment in the spring but declined over time in the fall (Table 2). During the fall, the rainfall was substantially greater, especially during the first month of the experiment when the herbicides were applied, when 201 mm fell in the fall, and 29 and 26 mm fell in spring 2018 and spring 2019, respectively.
Monthly weather data in 2018/2019. a
a Weather data were obtained from the weather station located at the Gulf Coast Research and Education Center in Balm, FL, as obtained from the Florida Automated Weather Network.
Data collection included tomato and pepper crop injury, height, and yield for both crops, and weed count in all trials. Crop injury was evaluated on a percent scale, where 0% represented no visual injury and 100% represented complete plant desiccation. In the tomato trial I, the visual injury was evaluated at 4 and 6 WATP (April 6 and April 19, 2018, respectively). The height of 20 plants per plot was measured with a meter stick (cm), for tomato trial I at 5, 7, and 10 WATP (April 9, April 23, and May 18, 2018, respectively). Total weeds in the planting hole were counted in in each plot at 10 WATP (May 18, 2018), and at 11, 13 and 15 WATP (May 22, June 4, and June 19, 2018). Sites were selected with limited weed pressure because the focus was crop tolerance. Accordingly, few weeds emerged, and we did not attempt to distinguish weed species. The number of living crop plants were counted in each plot, harvest at season end, and the fruits weighed. On tomato Trial II, visual injury and height were evaluated at 2 and 5 WATP (September 11 and October 5, 2018, respectively), weeds were counted at 2 and 4 WATP (September 11 and September 25, 2018, respectively), and harvest occurred at 8 WATP (October 25, 2018).
During Trial I, pepper height was evaluated at 6 WATP (September 25, 2018), weeds counted at 11 WATP (October 29, 2018), and harvested at 13 WATP (November 15). For Trial II, visual injury was evaluated at 3 and 5 WATP (April 4 and April 16, 2018, respectively), height and weed density were evaluated at 5 WATP (April 17, 2019), and harvest occurred at 10 a 12 WATP (May 23 and June 6, 2019, respectively).
Statistical Analysis
Data were subject to ANOVA using the MIXED procedure in SAS software (version 9.4; SAS Institute, Cary, NC). Data were subjected to one-way ANOVA, and herbicides are considered as the fixed factor, while the block was considered as the random factor. Constant variance and normality were examined. Treatments means were separated using Scott-Knott multiple comparisons at P ≤ 0.05. Data collected on multiple dates, such as visual injury and height, were analyzed using the repeated measure analysis.
Results and Discussion
The herbicides applied in this study did not significantly affect tomato injury in Trial II (P = 0.57989), heights (P = 0.56253 and P = 0.52698 in trials I and II, respectively), yield (P = 0.7413, and P = 0.86630 in Trial I and II, respectively), and weed density in the planting holes (P = 0.12692 and P = 0.148203 in Trial I and II, respectively; Table 3). Fomesafen injury on tomato was observed in Trial I with an average of 7% injury. Injury following application of all other evaluated herbicides was less than 5%, and although fomesafen caused significantly more injury compared to other herbicides in Trial I, it did not significantly reduce tomato height or yield in either season. We conclude that all herbicides, with the exception of fomesafen can be safely applied after transplant.
Effects of herbicide when applied with a precision applicator that targets plant holes in plastic mulch on tomato height, total marketable yield, and weed density. a , e
a Abbreviation: WATP, weeks after transplant.
b Injury ratings are the average of measurements taken 4 and 5 WATP for the Trial I and 2 and 5 WATP for the Trial II. For injury, all ratings were compared with the nontreated control, but assigned nontreated control ratings of 0 were removed prior to analysis.
c Tomato heights were measured at 5, 7 and 8 WATP in Trial I and 2 and 5 WATP Trial II, respectively
d Weed density was measured at 10 WATP in Trial I and 2 and 4 WATP in Trial II.
e Treatments mean with the same column followed by the same letter is statistically equivalent according to Scott-Knott adjusted means comparisons at the 0.05 significance level.
Similar results were observed by Yu et al. (Reference Yu, Boyd, Schumann and Sharpe2021), when the use of a banded application of S-metolachlor and metribuzin on the tomato planting holes presented slight crop injury, and fomesafen caused an average of 7% injury, but no reduction in crop growth or yield were observed. The potential injury risk by fomesafen was previous reported by Mohseni-Moghadam and Doohan (Reference Mohseni-Moghadam and Doohan2017a), when fomesafen was applied 1 d before transplant on processing tomato. Tomato injury ranged from 0% to 28%, with the crop completely recovered, and no effects on the final yield were reported, showing that even previously applied fomesafen can result in considerable potential injury to tomato plants.
The results for pepper (Table 4) also indicated that there was no significant effect of herbicide type on yield (P = 0.50290, and P = 0.49633 in Trial I and II, respectively). All the herbicides caused significant crop injury (≥19%). Fomesafen and metribuzin caused significant pepper injury, with an average of 59% injury for fomesafen and 80% for metribuzin. Both herbicides also stunted the pepper shoots in Trial II with an average reduction of 11 cm and 8 cm for metribuzin and fomesafen respectively, when compared with the heights of plants with other herbicide treatments. We conclude that the injury observed would not be acceptable to growers, and therefore, none of the options can be considered safe.
Effect of herbicide when applied with a precision applicator that targets plant holes in plastic mulch on bell pepper height, total marketable yield, and weed density. a , e
a Abbreviation: WATP, weeks after transplant.
b Injury ratings are the average of measurements at 3 and 5 WATP for Trial II. For injury, all ratings were compared with the nontreated control, but assigned nontreated control ratings of 0 were removed prior to analysis.
c Pepper heights were measured at 6 and 5 WATP in Trial I and Trial II, respectively
d Weed density was measured at 11 WATP in Trial I and 5 WATP in Trial II.
e Treatments mean with the same column followed by the same letter is statistically equivalent according to Scott-Knott adjusted means comparisons at the 0.05 significance level.
Grey et al. (Reference Grey, Bridges and NeSmith2002) observed pepper foliage injuries when fomesafen was applied PRE or posttransplant on the day of transplanting with damage ranging from 0% to 14%. Grey et al. (Reference Grey, Bridges and NeSmith2002) observed no effect on yield with transient damage that was visible only 7 to 10 d after application. Less than 9% injury was observed when S-metolachlor and halosulfuron were applied posttransplant, and as shown in this study the crops recovered (Bangarwa et al. Reference Bangarwa, Norsworthy and Gbur2009; Devkota et al. Reference Devkota, Norsworthy and Rainey2015).
In all Trials, the weed density in the planting holes was unaffected by the herbicide type (P = 0.12692, P = 0.148203, P= 0.2444, and P=0.22583 in tomato Trial I, tomato Trial II, pepper Trial I, and pepper Trial II, respectively; Tables 3 and 4). The results of the current study agree with those of previous research in which no differences in weed control have been reported with herbicide treatments using the hole-punch smart sprayer (Boyd and Schumann Reference Boyd and Schumann2018). This was expected because low weed density areas were selected, and because the focus was to confirm the tolerance of tomato and pepper plants when herbicides are applied in established transplanted plants with a precision herbicide applicator.
We conclude that halosulfuron, S-metolachlor, metribuzin and pendimethalin are safe to apply posttransplant in tomato 2 WATP. However, the use of fomesafen can cause significant injuries to tomato plants, although no decrease in yield was observed. None of the evaluated herbicides can be recommended as a safe option for PRE weed control on posttransplant pepper. We conclude that we have identified multiple PRE herbicides that can be safely applied after transplant in tomato but were unable to identify a safe option for pepper.
Acknowledgments
We acknowledge the technical assistance of Mike Sweat, Laura Reuss, and the farm crew at the Gulf Coast Research and Education Center for assistance with crop management. This research was funded by a specialty crop block grant EAM190100XXXXG036. No conflicts of interest have been declared.
Open access
