Skip to main content
×
×
Home

Turbulence attenuation in simultaneously heated and cooled annular flows at supercritical pressure

  • Jurriaan W. R. Peeters (a1) (a2), R. Pecnik (a1), M. Rohde (a2), T. H. J. J. van der Hagen (a2) and B. J. Boersma (a1)...
Abstract

Heated or cooled fluids at supercritical pressure show large variations in thermophysical properties, such as the density, dynamic viscosity and molecular Prandtl number, which strongly influence turbulence characteristics. To investigate this, direct numerical simulations were performed of a turbulent flow at supercritical pressure (CO $_{2}$ at 8 MPa) in an annulus with a hot inner wall and a cold outer wall. The pseudo-critical temperature lies close to the inner wall, which results in strong thermophysical property variations in that region. The turbulent shear stress and the turbulent intensities significantly decrease near the hot inner wall, but increase near the cold outer wall, which can be partially attributed to the mean dynamic viscosity and density stratification. This leads to decreased production of turbulent kinetic energy near the inner wall and vice versa near the outer wall. However, by analysing a transport equation for the coherent streak flank strength, it was found that thermophysical property fluctuations significantly affect streak evolution. Near the hot wall, thermal expansion and buoyancy tend to decrease streak coherence, while the viscosity gradient that exists across the streaks interacts with mean shear to act as either a source or a sink in the evolution equation for the coherent streak flank strength. The formation of streamwise vortices on the other hand is hindered by the torque that is the result of the kinetic energy and density gradients. Near the cold wall, the results are reversed, i.e. the coherent streak flank strength and the streamwise vortices are enhanced due to the variable density and dynamic viscosity. The results show that not only the mean stratification but also the large instantaneous thermophysical property variations that occur in heated or cooled fluids at supercritical pressure have a significant effect on turbulent structures that are responsible for the self-regeneration process in near-wall turbulence. Thus, instantaneous density and dynamic viscosity fluctuations are responsible for decreased (or increased) turbulent motions in heated (or cooled) fluids at supercritical pressure.

Copyright
Corresponding author
Email address for correspondence: j.w.r.peeters@tudelft.nl
References
Hide All
Bae, J. H., Yoo, J. Y. & Choi, H. 2005 Direct numerical simulation of turbulent supercritical flows with heat transfer. Phys. Fluids 17, 105104.
Bae, J. H., Yoo, J. Y. & McEligot, D. M. 2008 Direct numerical simulation of heated CO2 flows at supercritical pressure in a vertical annulus at Re = 8900. Phys. Fluids 20, 055108.
Batchelor, G. K. 1959 Small-scale variation of convected quantities like temperature in turbulent fluid. Part 1. General discussion and the case of small conductivity. J. Fluid Mech. 5, 113133.
Bladel, J. 2007 Electromagnetic Fields. Wiley, IEEE Press.
Boersma, B. J. 2011a A 6th order staggered compact finite difference method for the incompressible Navier–Stokes and scalar transport equations. J. Comput. Phys. 230 (12), 49404954.
Boersma, B. J. 2011b Direct numerical simulation of turbulent pipe flow up to a Reynolds number of 61 000. J. Phys.: Conf. Ser. 318.
Boersma, B. J. & Breugem, W.-P. 2011 Numerical simulation of turbulent flow in concentric annuli. Flow Turbul. Combust. 86 (1), 113127.
Carr, A. D., Connor, M. A. & Buhr, H. O. 1973 Velocity, temperature, and turbulence measurements in air for pipe flow with combined free and forced convection. Trans. ASME C: J. Heat Transfer 95 (4), 445452.
Cheng, R. K. & Ng, T. T. 1982 Some aspects of strongly heated turbulent boundary layer flow. Phys. Fluids 25 (8), 13331341.
Corino, E. R. & Brodkey, R. S. 1969 A visual investigation of the wall region in turbulent flow. J. Fluid Mech. 37, 130.
Duan, L., Beekman, I. & Martin, M. P. 2011 Direct numerical simulation of hypersonic turbulent boundary layers. Part 3. Effect of Mach number. J. Fluid Mech. 672, 245267.
Fenghour, A., Wakeham, W. A. & Vesovic, V. 1998 The viscosity of carbon dioxide. J. Phys. Chem. Ref. Data 27, 3144.
Gurtin, M. E., Fried, E. & Anand, L. 2010 The Mechanics and Thermodynamics of Continua. Cambridge University Press.
Hamilton, J. M., Kim, J. & Waleffe, F. 1995 Regeneration mechanisms of near-wall turbulence structures. J. Fluid Mech. 287, 317348.
Jackson, J. D. 2013 Fluid flow and convective heat transfer to fluids at supercritical pressure. Nucl. Engng Des. 264, 2440.
Jimenez, J. & Pinelli, A. 1999 The autonomous cycle of near-wall turbulence. J. Fluid Mech. 389, 335359.
Kawamura, H., Ohsaka, K., Abe, H. & Yamamoto, K. 1998 DNS of turbulent heat transfer in channel flow with low to medium-high Prandtl number fluid. Intl J. Heat Fluid Flow 19, 482491.
Kim, J. 2011 Physics and control of wall turbulence for drag reduction. Phil. Trans. R. Soc. Lond. A 369, 13961411.
Kunz, O., Klimeck, R, Wagner, W. & Jaeschke, M.2007 The GERG-2004 wide-range equation of state for natural gases and other mixtures. Tech. Rep., GERG Technical Monograph 15, Fortschritt-Berichte VDI. VDI-Verlag.
Kurganov, V. A. & Kaptil’ny, A. G. 1992 Velocity and enthalpy fields and eddy diffusivities in a heated supercritical fluid flow. Exp. Therm. Fluid Sci. 5 (4), 465478.
Lee, J., Jung, A. Y., Sung, J. J. & Zaki, T. A. 2013 Effect of wall heating on turbulent boundary layers with temperature-dependent viscosity. J. Fluid Mech. 726, 196225.
Lemmon, E. W., Huber, M. L. & McLinden, M. O.2013 NIST Standard Reference Database 23: Reference Fluid Thermodynamic and Transport Properties – REFPROP Version 9.1. Standard Reference Data Program. National Institute of Standards and Technology.
McMurtry, P. D., Jou, W.-H., Riley, J. & Metcalfe, R. W. 1986 Direct numerical simulations of a reacting mixing layer with chemical heat release. AIAA J. 24 (6), 962970.
Najm, H. N., Wyckoff, P. S. & Knio, O. M. 1998 A semi-implicit numerical scheme for reacting flow: I. Stiff chemistry. J. Comput. Phys. 143 (2), 381402.
Nemati, H., Patel, A., Boersma, B. J. & Pecnik, R. 2015 Mean statistics of a heated turbulent pipe flow at supercritical pressure. Intl J. Heat Mass Transfer 83, 741752.
Nishikawa, K. & Tanaka, I. 1995 Correlation lengths and density fluctuations in supercritical states of carbon dioxide. Chem. Phys. Lett. 244, 149152.
Patel, A., Peeters, J. W. R., Boersma, B. J. & Pecnik, R. 2015 Semi-local scaling and turbulence modulation in variable property turbulent channel flows. Phys. Fluids 27, 095101.
Petukhov, B. S. & Polyakov, A. F. 1988 Heat Transfer in Turbulent Mixed Convection. Hemisphere.
Schoppa, W. & Hussain, F. 2002 Coherent structure generation in near-wall turbulence. J. Fluid Mech. 453, 57108.
Shiralkar, B. B. & Griffith, P. P. 1970 The effect of swirl, inlet conditions, flow direction, and tube diameter on the heat transfer to fluids at supercritical pressure. Trans. ASME: J. Heat Transfer 92 (3), 465471.
Tennekes, H. & Lumley, J. L. 1972 A First Course in Turbulence. MIT Press.
Vesovic, V., Wakeham, W., Olchowy, G., Sengers, J., Watson, J. & Millat, J. 1990 The transport properties of carbon dioxide. J. Phys. Chem. Ref. Data 19, 763808.
Waleffe, F. 1997 On a self-sustaining process in shear flows. Phys. Fluids 9, 883900.
Wang, J., Shi, Y., Wang, L.-P., Xiao, Z., He, X. T. & Chen, S. 2012 Effect of compressibility on the small-scale structures in isotropic turbulence. J. Fluid Mech. 713, 588631.
Willmarth, W. W. & Lu, S. S. 1972 Structure of the Reynolds stress near the wall. J. Fluid Mech. 55, 6592.
Yoo, J. Y. 2013 The turbulent flows of supercritical fluids with heat transfer. Annu. Rev. Fluid Mech. 45 (1), 495525.
Zappoli, B., Beysens, D. & Garrabos, Y. 2015 Heat Transfers and Related Effects in Supercritical Fluids. Springer.
Zonta, F. 2013 Nusselt number and friction factor in thermally stratified turbulent channel flow under non-Oberbeck–Boussinesq conditions. Intl J. Heat Fluid Flow 44, 489494.
Zonta, F., Marchioli, C. & Soldati, A. 2012 Modulation of turbulence in forced convection by temperature-dependent viscosity. J. Fluid Mech. 697, 150174.
Zonta, F., Marchioli, C. & Soldati, A. 2012 Turbulence and internal waves in stably-stratified channel flow with temperature-dependent fluid properties. J. Fluid Mech. 697, 175203.
Zonta, F. & Soldati, A. 2014 Effect of temperature dependent fluid properties on heat transfer in turbulent mixed convection. Trans. ASME: J. Heat Transfer 136, 022501.
Recommend this journal

Email your librarian or administrator to recommend adding this journal to your organisation's collection.

Journal of Fluid Mechanics
  • ISSN: 0022-1120
  • EISSN: 1469-7645
  • URL: /core/journals/journal-of-fluid-mechanics
Please enter your name
Please enter a valid email address
Who would you like to send this to? *
×
MathJax

JFM classification

Metrics

Full text views

Total number of HTML views: 0
Total number of PDF views: 0 *
Loading metrics...

Abstract views

Total abstract views: 0 *
Loading metrics...

* Views captured on Cambridge Core between <date>. This data will be updated every 24 hours.

Usage data cannot currently be displayed